View MDX-C7900_176269.PDF datasheet online --- IC-ON-LINE

Datasheet File OCR Text:

www..com
MDX-C7900/C7900R
SERVICE MANUAL
Ver 1.1 2001.08
US Model Canadian Model E Model
MDX-C7900
AEP Model UK Model
MDX-C7900R
Refer to RM-X4S Service Manual (9-925698-[][]) issued previously for information of remote commander (RM-X4S) supplied with this set.
Photo: MDX-C7900
Model Name Using Similar Mechanism Base Mechanism Type Optical Pick-Up Name
NEW MG-164KT-138 KMS-241A/J2N
SPECIFICATIONS
- Continued on next page -
MDX-C7900
FM/AM MINIDISC PLAYER
MDX-C7900R
FM/MW/LW MINIDISC PLAYER
www..com
9-925-787-12
2001H0500-1 C 2001.8
Sony Corporation
e Vehicle Company Shinagawa Tec Service Manual Production Group
www..com
Ver 1.1
TABLE OF CONTENTS 1. 2. SERVICE NOTE ....................................................... 3 GENERAL
Location of Controls (MDX-C7900) .............................. 4 Location of Controls (MDX-C7900R) ........................... 5 Resetting the Unit ........................................................... 6 Detaching the Front Panel ............................................... 6 Preparing the Rotary Commander .................................. 6 Setting the Clock ............................................................. 6 Installation (US, Canadian) ............................................ 7 Installation (AEP, UK, E) ............................................... 8 Connections ..................................................................... 10
3. 4.
DISASSEMBLY ......................................................... 13 ELECTRICAL ADJUSTMENTS
Test Mode ........................................................................ 18 MD Section ..................................................................... 18 Tuner Section .................................................................. 18
5.
DIAGRAMS
5-1. Block Diagram - SERVO Section - ............................... 21 5-2. Block Diagram - MAIN Section - ................................. 23 5-3. Block Diagram - DISPLAY/KEY CONTROL Section - ........................ 25 5-4. Block Diagram - BUS CONTROL/POWER SUPPLY Section - ........... 27 5-5. Printed Wiring Boards - MECHANISM DECK Section - ................................. 29 5-6. Schematic Diagram - MECHANISM DECK Section - ................................. 31 5-7. Schematic Diagram - MAIN Section - .......................... 35 5-8. Printed Wiring Board - MAIN Section - ....................... 39 5-9. Printed Wiring Board - PANEL Section - ..................... 43 5-10. Schematic Diagram - PANEL Section - ........................ 45 5-11. IC Pin Function Description ........................................... 55
6. 7.
EXPLODED VIEWS ................................................ 64 ELECTRICAL PARTS LIST ............................... 68
www..com
-2-
www..com
SECTION 1 SERVICE NOTE
* Type A/B Discrimination
[MAIN BOARD] (Component Side)
Flexible Circuit Board Repairing * Keep the temperature of the soldering iron around 270 C during repairing. * Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). * Be careful not to apply force on the conductor when soldering or unsoldering. Notes on chip component replacement * Never reuse a disconnected chip component. * Notice that the minus side of a tantalum capacitor may be damaged by heat. CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT A LA SECURITE! LES COMPOSANTS IDENTIFIES PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHEMATIQUES ET LA LISTE DES PIECES SONT CRITIQUES POUR LA SECURITE DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIECES SONY DONT LES NUMEROS SONT DONNES DANS CE MANUEL OU DANS LES SUPPLEMENTS PUBLIES PAR SONY.
IC700
MB90574PFV-G-113-BND (C7900R: Type A) MB90574PFV-G-114-BND (C7900: Type A) MB90F574PFV-G-113 (C7900R: Type B) MB90F574PFV-G-114 (C7900: Type B)
www..com
-3-
www..com
This section is extracted from instruction manual.
SECTION 2 GENERAL
www..com
-4-
www..com
www..com
-5-
www..com
www..com
-6-
www..com
www..com
-7-
www..com
www..com
-8-
www..com
www..com
-9-
www..com
www..com
- 10 -
www..com
www..com
- 11 -
www..com
www..com
- 12 -
www..com
SECTION 3 DISASSEMBLY
Note: Follow the disassembly procedure in the numerical order given.
FRONT PANEL
2
1 Push the button (release).
3 Remove the front panel of the arrow.
COVER ASS'Y, PANEL (SUB) ASS'Y
1
2 cover ass'y
4 panel (sub) ass'y
3 four screws (PTT2.6 x 6)
1
www..com
3 screw (PTT2.6 x 6)
- 13 -
www..com
MECHANISM DECK (MG-164KT-138)
1 two screws (PTT2.6 x 4)
2 mechanism deck (MG-164KT-138)
MAIN BOARD
1 eight screws (PTT2.6 x 10)
3 three screws (PTT2.6 x 6) (ground point)
1 two screws (PTT2.6 x 10)
2 heat sink 4 main board
5 insulating sheet
www..com
- 14 -
www..com
SERVO BOARD
3 two screws (BVTT2 x 4) 3 two screws (BVTT2 x 4)
4 servo board
1 sensor flexible board (CN102)
2 flexible board (CN103)
FLOAT BLOCK
5 Pushing an arrw A part, raise the float block up ward at the front to release a lock. A 3 spring (FL2)
2 MD cover ass'y
1 four screws (BVTT2 x 4)
float block
lever (lock R) lever (lock L) Release of the lock.
www..com
4 two springs (FL)
3 spring (FL2)
- 15 -
www..com
HOLDER ASS'Y
5 holder ass'y
1 spring (CHKG)
4 washer (M)
2 stop ring E (1.5)
3 lever (lock R)
1 spring (CHKG) 3 lever (lock L) 2 stop ring E (1.5)
OPTICAL PICK-UP (KMS-241A/J2N)
4 screw (B2 x 3) 6 bearing (SL) 5 feed screw ass'y 7 optical pick-up (KMS-241A/J2N)
1 two screws (K2 x 3)
3 screw (K2 x 3)
2 shaft (SL2)
www..com
- 16 -
www..com
MOTOR ASS'Y (M901, M902, M903), SENSOR BOARD
4 screw (P1.7 x 1.8) 9 two screws (P1.7 x 1.8) 5 bracket (SL) 2 two screws (2 x 8) 6 motor ass'y (M902)
0 motor ass'y (M901)
7 screw (B2 x 3)
3 sensor board
8 base (SL) !TM motor ass'y (M903) ! screw (P2 x 2.2)
1 Remove the solders of motor (M901, M902, M903).
www..com
- 17 -
www..com
SECTION 4 ELECTRICAL ADJUSTMENTS
TEST MODE This set have the test mode function. In the test mode, FM Auto Scan/Stop Level and AM (MW) Auto Scan/Stop Level adjustments can be performed easier than it in ordinary procedure. 1. Set the "power select" switch (S700) is "A (ON)" position. 2. Turn ON the regulated power supply. (All LEDs on the set lights up, and the clock is displayed.)
Note: Press the
3. Adjust with the volume RV2 on TU1 so that the "FM" indication turns to "FM0" indication on the display window. But, in case of already indicated "FM0", turn the RV2 so that put out light "0" indication and adjustment. Display
SHUF *1 REG
[OFF]
button, if the clock is not displayed.
3. 4. 5. 6.
Push the preset [4] button. Push the preset [5] button. Press the preset [1] button for more than two seconds. Then the display indicates all lights, the test mode is set.
*1: MDX-C7900R is indicates "98.00". Adjustment Location: See page 20. FM Stereo Separation Adjustment Setting: [SOURCE] button: FM
FM RF signal generator antenna jack (J1) 0.01 F set speaker out terminal
MDX-C7900 Carrier frequency Output level Mode main Modulation sub 19 kHz pilot 97.9 MHz 60 dB (1 mV) stereo 1 kHz, 33.75 kHz deviation (45%) 1 kHz, 33.75 kHz deviation (45%) 7.5 kHz deviation (10%) MDX-C7900R 98.0 MHz 70 dB (3.2 mV) stereo 1 kHz, 20 kHz deviation (22.6%) 1 kHz, 20 kHz deviation (22.6%) 7.5 kHz deviation (10%)
1. Push the [OFF] button. 2. Return the "power select" switch (S700) to initially set position. See the adjustment location from on page 20 for the adjustment.
level meter 4 + -
MD SECTION
MD section adjustments are done automatically in this set.
TUNER SECTION
0 dB=1 V
Cautions during repair When the tuner unit is defective, replace it by a new one because its internal block is difficult to repair.
Note: Adjust the tuner section in the sequence shown below.
1. 2. 3. 4.
FM Auto Scan/Stop Level Adjustment. FM Stereo Separation Adjustmnet. AM (MW) Auto Scan/Stop Level Adjustment. RDS S-Meter Adjustment. Procedure:
FM Auto Scan/Stop Level Adjustment Setting: [SOURCE] button: FM
FM RF signal generator antenna jack (J1) 0.01 F set Carrier frequency: 97.9 MHz (MDX-C7900) 98.0 MHz (MDX-C7900R) Output level : 22 dB (12.6 V) Mode : mono Modulation : 1 kHz, 22.5 kHz deviation (30%)
FM Stereo signal generator output channel L-CH R-CH R-CH L-CH
Level meter connection L-CH L-CH R-CH R-CH
Level meter reading (dB) A B Adjust RV4 on TU1 for minimum reading. C D Adjust RV4 on TU1 for minimum reading.
Procedure: 1. Set to the test mode. 2. Push the [SOURCE] button and set to FM. Display
SHUF *1
L-CH Stereo separation: A-B R-CH Stereo separation: C-D The separations of both channels should be equal. Specification: Separation more than 30 dB Adjustment Location: See page 20.
www..com
REG
- 18 -
www..com
AM (MW) Auto Scan/Stop Level Adjustment Setting: [SOURCE] button (MDX-C7900): AM [SOURCE] button (MDX-C7900R): MW
30 15 pF 65 pF AM RF signal generator AM dummy antenna (50 )
RDS S-Meter Adjustment (MDX-C7900R) Setting: [SOURCE] button: FM
FM RF signal generator antenna jack (J1) 0.01 F set Carrier frequency: Output level : Mode : Modulation : 98.0 MHz 35 dB (56.2 V) mono no modulation
Adjustment Location:
- SET UPPER VIEW -
RV1 RDS S-METER Adjustment
TU1
set
antenna jack (J1) Carrier frequency: 1000 kHz (MDX-C7900) 999 kHz (MDX-C7900R) 30% amplitude modulation by 1 kHz signal Output level : 33 dB (44.7 V)
Procedure: 1. Set to the test mode. (See page 18.) 2. Push the [SOURCE] button and set to FM. Display
SHUF
RV1 AM (MW) AUTO SCAN/STOP LEVEL Adjustment
REG
Procedure: 1. Set to the test mode. (See page 18.) 2. Push the [SOURCE] button and set to FM. 3. Push the [MODE] button and set to AM (MDX-C7900) or MW (MDX-C7900R). Display
*2 *3 TP REG SHUF
RV2 FM AUTO SCAN/STOP LEVEL Adjustment
3. Push the preset [10] button. 4. Adjust RV1 on MAIN board so that the display indication is "15.8". Display
SHUF
RV4 FM STEREO SEPARATION Adjustment
REG
Specification: Display indication : 15.6 to 16.4 Adjustment Location: See page 20.
4. Adjust with the volume RV1 on TU1 so that the "AM" or "MW" indication turns to "AM0" or "MW0" indication on the display window. But, in case of already indicated "AM0" or "MW0", turn the RV1 so that put out light "0" indication and adjustment. Display
*2 *3 TP REG SHUF
*2: MDX-C7900R is indicates "MW". *3: MDX-C7900R is indicates "999". Adjustment Location: See page 20.
www..com
- 19 -
- 20 -
MDX-C7900/C7900R
www..com
SECTION 5 DIAGRAMS
15 TX 100 EFMO IC301 (1/2)
5-1. BLOCK DIAGRAM - SERVO Section -
* SIGNAL PATH
ADDT 23
: MD PLAY
DIGITAL SIGNAL PROCESSOR, EFM/ACIRC ENCODER/DECODER, SHOCK PROOF MEMORY CONTROLLER, ATRAC ENCODER/DECODER, 2M BIT D-RAM IC301 (1/2)
SHOCK PROOF MEMORY CONTROLLER
EFM/ACIRC ENCODER/DECODER
48 47
MORFO MORFI
RF AMP, FOCUS/TRACKING ERROR AMP IC302 51 52 RFO 46 40 AGCI RF AGC & EQ EQ B.P.F. WBL AUX 33 RF 38 55 ASYO ASYI RFI COMPARATOR
ATRAC ENCODER/DECODER
FILI 59 PCO 58 CLTV 61 FILO 60
FILTER
PLL
SAMPLING RATE CONVERTER
DIGITAL AUDIO INTERFACE
DIN 21 DOUT 22
DADT
A B
(Page 5)
I J
1 2
I J
DADT
BCK, LRCK, FS256
24
BCK LRCK FS256
(Page 5)
RF AMP
26 25 27
XBCK LRCK FS256
D-RAM PEAK BOTM 37 36
ADFG
F B
3T
TEMP PEAK & BOTTOM WBL
CLOCK GENERATOR
OSCI OSCO
16 17
512FS OSC IC304
X301 22.5792MHz
A E DETECTOR C D E F
XRST DQSY
8 9
E F
I-V AMP
TRACKING ERROR AMP COMMAND
SE
26 28
94 93 10 LASER DIODE ILCC PD LD PD AUTOMATIC POWER CONTROL Q302 APC 11
WBL 3T EQ
12
11
14
98
567
MNT0 MNT1 MNT2 MNT3
SPRD
SQSY
SENS SRDT
SPFD
XINT
TE
1234 XOE XWE XRAS XCAS
LD/PD AMP
F0CNT
10
SWDT SCLK XLAT
PD
APCREF
12 2 4 6
V-I CONVERTER
SERIAL/ PARALLEL CONVERTER, DECODER
5
13 LEVEL SHIFT IC502
31
LEVEL SHIFT IC503 42
41 45 44 42
22 3 4 23
6
12
13 1 3 5
12 OPTICAL PICK-UP (KMS-241A/J2N) FOCUS/TRACKING COIL DRIVE, SPINDLE/SLED MOTOR DRIVE IC303
20 +3.3V
16 17 18
FOK SHOCK XBUSY SLOCK
TH501
SWDT SCLK XLAT
9 - 12, 14 - 18, 5 A0 - A9
34
79
32 - 29, 34 - 38, 43
FOCUS ERROR AMP
FE
F0CNT
SPINDLE SERVO
SWDT SCLK XLAT
A00 - A09
4 5 6 7
A B C D
B.P.F.
29
30
32
78
I-V AMP
ABCD AMP
ABCD
35 CPU INTERFACE MONITOR CONTROL
1, 2, 24, 25 D0 - D3
D
A
AT AMP
ADFG
47, 46, 48, 49
I
C
B
J
ADFM
ADIN
ADIP DEMODULATOR/ DECODER
SUBCODE PROCESSOR
INTERNAL BUS
D0 - D3
OE WE RAS CAS
D-RAM IC307
LOCK
PSB 16 PEAK HOLD Q301 SPFD SPRD +3.3V 13 RECP APCREF 83 M902 (SLED) SFDR 92 SRDR 91
PWM GENERATOR
C
(Page 5)
ABCD 59
MD-RST
62
SQSY
55
CC-XINT
54 52
SENS MD-SI
45 51 64
MD-SO MD-CKO MD-LAT
26 27 28 29
MNT0 MNT1 MNT2 MNT3
39
TEMP
21
LOCK
M901 (SPINDLE)
M
6 OUT4F 8 OUT4R
IN4R 3 IN4F 4
IC306
66 75 64 65 74 73 62 63
AUX1 AUX2 ABCD FE TE SE PEAK BOTM
EXTAL
31 X501 10MHz
EJECT
LOAD
C-SW
M
27 OUT2F 25 OUT2R
IN2F 29 IN2R 30
A/D CONVERTER DIGITAL SERVO SIGNAL PROCESS
7
6
63
11
E-SW
ANALOG MUX
56
2-AXIS DEVICE
(TRACKING) (FOCUS)
FCS+
21 OUT1F 23 OUT1R
IN1F 19 IN1R 18
FFDR 88 FRDR 89
FROM CPU INTERFACE XLRF CKRF DTRF
5 LOADING MOTOR DRIVE IC305 RIN
4 FIN LOADING START/ EJECT END LOADING END
(LIMIT) ON: When the optical pick-up is inner position. (ON: When completion of the disc loading.)
FCS- www..com TRK+ TRK- 12 OUT3F 10 OUT3R IN3F 14 IN3R 15
AUTO SEQUENCER TFDR 86 TRDR 85 DIGITAL SERVO SIGNAL PROCESSOR IC301 (2/2)
80 81 82
OUT1 OUT2 1 7 M903 (LOADING)
ON: When the disc loading start and thedisc eject completion.
M
05
- 21 -
- 22 -
LIMIT-IN
AUTOMATIC POWER CONTROL
MD MECHANISM CONTROLLER IC501 (1/2)
XTAL
32
www..com
MDX-C7900/C7900R
5-2. BLOCK DIAGRAM - MAIN Section -
DIGITAL D-BASS CONTROL IC201
DIGITAL FILTER, D/A CONVERTER IC202 DOUT 9 BCKO 10 LRCO 11 DATA 5 BCK 6 LRCK 4 7 SEQUENTIAL CONTROL 1 ZERO XTI CLK CONTROL VOUTL INPUT INTERFACE DIGITAL FILTER NOISE SHAPER D/A CONVERTER 12 VOUTR 9 R-CH LOW-PASS FILTER IC203 MUTING Q991 R-CH
A
(Page 4)
DADT
BCK LRCK
5 3 1
LEVEL SHIFT IC204
6 4 2
DI 3 BCKI 2 LRCI 1
* SIGNAL PATH : MD PLAY : FM : AM (MW)
INPUT INTERFACE CIRCUIT
DIGITAL SIGNAL PROCESSOR
OUTPUT INTERFACE CIRCUIT
COUNTER PD PHASE 2 COMPARATOR AMPI SELECTOR & VCO DIGITAL AUDIO PLL IC200
BCK, LRCK
MODE CONTROL
MUTE DM2
CKO 10 4
1
REF
4
CLK
SYSTEM CLOCK MODE CONTROL
MOD1 MOD2 DB/DS
18
17
MUTING CONTROL SWITCH Q903 MUTING Q301 R-CH
CNP300 (2/2)
(L) R-CH (R)
FRONT LINE OUT
14 15 16
MODE1 MODE2 EMPH
(L)
MUTING Q300 R-CH
B
(Page 4)
BCK, LRCK, FS256
FS256 R-CH (R)
REAR LINE OUT
CNP300 (1/2)
(L) (R)
BUS AUDIO IN
R-CH
FM B+ AM B+ D3 POWER AMP IC500 L3 (MD-L) 36 L4 (AUX-L) 35 INPUT L2 (FM-L) SELECTOR 37 L1 (AM-L) 38 MUTING Q101 R-CH
FM-DET
CNP500 (1/2) 1 FRONT L (+) 9 FRONT L (-) 4
J1 (FM/AM ANTENNA) 2 FM-ANT 1 AM-ANT
8
FM +B
10
AM +B
9
+B
LSELO 34 33
LVR IN
FM-L-CH 18 FM-R-CH 16
LT VOLUME OUT 28 CONTROL
27
LS IN
TONE CONTROL
LS OUT
23
22
LT IN
LF OUT FADER CONTROL LR OUT
FL+ 5 21 20 MUTING Q302 FR+ 21 R-CH R-CH 14 FR-IN FR- 23 RL+ 9 11 RL-IN RL- 7 MUTING Q303 RR+ 17 R-CH R-CH 15 RR-IN RR- 19
MUTE ST-BY
12 FL-IN FL- 3
R-CH
FM/AM TUNER UNIT TU1
SEEK SD ST/MONO S-METER AM-IF FM-IF
DI CL
CE
LO/DX VCO
ELECTRICAL VOLUME IC300
COMMAND
DECODER
SHIFT REGISTER & LATCH
FRONT R (+) 12 2 10 FRONT R (-) REAR L (+) REAR L (-)
CONTROL
VT
AM DET 12 MUTING Q100 R-CH (C7900R)
17 16 18
DATA CLK CE
46
21
11
5 (C7900R) AM B+ LOW-PASS FILTER Q4 AF SEEK SWITCHING Q5 IC103 LOW-PASS FILTER SWITCHING
13 20 22
19
23
3 11
REAR R (+) REAR R (-)
+
MUTING CONTROL SWITCH Q103 14
VDDA
B+ SWITCH Q51
BACKUP +5V FM B+
7
VDDD
22 RDS DECODER IC102 MUTING CONTROL SWITCH Q700
4 13 15 LEVEL SHIFT Q500 14 TEL ATT TEST ILL IN
9 16 15 11
LO/DX FM OSC AM OSC SEEK
13
IF
18
PD
SIGNAL QUALITY DECODER RDS/RDBS DEMODULATOR & DECODER
5 4 INTERFACE REGISTER
DOUT DIN CLK CE
FM/AM PLL IC100
RV1 RV1 SIGNAL METER
RDS SIGNAL BUFFER Q50
SC 57 kHz OUT 18 16 BAND-PASS MPX FILTER
MPTH
19
CIN
CLOCKED COMPARATOR
XI
1
20
XO
6542
20 X1 7.2MHz SIGNAL METER BUFFER Q1
LVIN
OSCO
DAVN
MULTI PATH DETECTOR
2
OSCILLATOR & CLOCK
OSCI
IIC BUS SLAVE TRANSCEIVER
SDA SCL
X2 4.332MHz 9 10 11 85
PLL SI PLL SO PLL CKO PLL CE
MODE1 MODE2 EMPH
DATA CLK CE
5
4
8
9
10
65
AF SEEK
82 83 81
SEEKOUT SD IN ST IN/MONO
53
S METER (VSM)
62
TU ATT
52
MPDH (MTP)
67
DAVN
70
RDS SI
71
RDS CKI
26 27 41
VOL SO VOL CKO VOL CE
31 16 59
DBMOD1 DBMOD2 EMPH O
60
AU ATT
55 56
AMP ON AMP ATT
80
TEL ATT
32 57
TESTIN ILL IN
C www..com (Page 4)
05
LOCK
58 LOCK IN
MASTER CONTROLLER IC700 (1/3)
- 23 -
- 24 -
MDX-C7900/C7900R
www..com
5-3. BLOCK DIAGRAM - DISPLAY/KEY CONTROL Section -
(LSW813: AEP, UK model only)
EN801 VOLUME/BASS/TREBLE/ BALANCE/FADER CONTROL
D900
LSW801 - 804, LSW806 - 821
J900 (REMOTE IN)
ROTARY ENCODER EN801 D912
LSW805 D-BASS
VOL+
VOL-
CNP801 FRONT PANEL SIDE
12
KEY ACTIVE SWITCH Q905
BACKUP +5V
CN900 MAIN BODY SIDE
12
BUZZER DRIVE Q701
BZ1 (BUZZER)
49 72
46
47
106 107
50
79
37
12
15
D-BASS IN
KEY IN1
AD ON
REIN0
REIN1
BAND (9K-10K)
MASTER CONTROLLER IC700 (2/3)
LCD SO LCD CKO LCD CE
NOSE SW
RC IN0 RC IN1
KEY IN0
KEYACK
BEEP
93
92
73
74
100
13 14 104
40
X700 3.68MHz
X701 32kHz S701 (FREQUENCY SELECT) MW 10K/FM 200K MW 9K/FM 50K (C7900: E model) LSW801, 804, 806, LSW808, 809 - 811, LSW813 - 821 LED DRIVE Q804 LED DRIVE Q803 (LSW813: AEP, UK model only) B+ SWITCH Q806 LCD +10V LCD +10V
D811 - 817, LSW802, 807, 812
CONTRAST SWITCHING Q901, 902 R845 OSC LIQUID CRYSTAL DISPLAY DRIVER IC801 21 20 18 17 19 22 - 25 KEY IN1 - KEY IN4 2 1 4 11 - 6 VLC0 - VLC5 Q802 Q801
BATT
DATA CLK STB
POWER ON
AMBER
OSC OUT
OSC IN
GREEN
SEG1 - SEG65 05 26 - 90
COM0 - COM7 100 - 93
DIMMER
3
DIMMER
LCD801 LIQUID CRYSTAL DISPLAY
LCDANG
X1A
X1
X0
X0A
D
(Page 10)
www..com
- 25 -
- 26 -
www..com
MDX-C7900/C7900R
5-4. BLOCK DIAGRAM - BUS CONTROL/POWER SUPPLY Section -
BATT (POWER AMP (IC500) B+) MASTER CONTROLLER IC700 (3/3) BACKUP +5V RESET SIGNAL GENERATOR IC801 S900 (RESET) SONY BUS INTERFACE IC600 RST RESET SWITCH RST RAM RESET IC802 D702 +9V (FOR VT) 13 29 SYSRET RAMBU 102 BACKUP +5V +9V REGULATOR Q2 FM B+ (FM CIRCUIT B+) AM B+ (AM CIRCUIT B+) COM +8V (ELECTRICAL VOLUME (IC300) B+) 6 ANP+B 8 AMT+B REGULATOR IC800 11 FM8V 10 AM8V F1 9 COM8V VCC 7 16 BATT 90 RESET +5V (FM/AM PLL (IC100) B+) CNP500 (2/2) 6 +5V REGULATOR Q6 ANT REM AMP REM 5
CNJ600 BUS CONTROL IN (FOR SONY BUS) 2 RESET 2
5 DATA 6
DATA
DATA IN DATA OUT
9 8 11
21 UNI SO 20 UNI SI 22 UNI CKO PW SEL 95
S700 (POWER SELECT) ON OFF
4 CLK 6 BUS ON BUS ON SWITCH Q600 4
CLK
CLK IN
D803 BACKUP +5V (Type B)
5 BU+B
STB MODE1 MODE2
BUS ON BUS OUT BUS ON ON IN 1 12 SWITCH
36 BUS-ON PULLUP +5V PW ON 109 FM ON 110
4
3
2
7 BATT 3
BATT
BATTERY BU IN 10 SWITCH
76 BU IN TUN ON 111
D701 LAMP ON (ILL ON) 108 ACC IN 64
TH600
D604 D603
+5V REGULATOR IC900 (Type A)
BATT B+
BATTERY DETECT Q601 LCD +10V (LCD DRIVER (IC801) B+) PL801, 802 (FOR BACK LIGHT) 60 BU-IN 61 BUS-ON 30 RESET 49 UNISI 48 UNICKI LEVEL SHIFT Q603 50 UNISO
MD MECHANISM CONTROLLER IC501 (2/2)
BACK LIGHT LAMP DRIVE Q805, 807
+10V REGULATOR Q903, 904
REGULATOR CONTROL SWITCH Q906
LOAD +12V LOADING MOTOR DRIVER (IC305) B+ +5V REGULATOR Q252
D/A +5V 46 LINKOFF REGULATOR CONTROL SWITCH Q253
B+ SWITCH Q402, 403 MD-ON 65 MDMON 10
VCC
+12V REGULATOR Q254
REGULATOR CONTROL SWITCH Q255 DRIVER +5V MOTOR/COIL DRIVER (IC303) B+ DC/DC CONVERTER IC250 B+ SWITCH Q250
+3.3V
+3.3V REGULATOR IC401, Q401
05 ACCESSORY CHECK Q900
Q251 D913 7 ACC
www..com
DIMMER
D
(Page 8)
- 27 -
- 28 -
MDX-C7900/C7900R
www..com
5-5. PRINTED WIRING BOARDS - MECHANISM DECK Section -
* Semiconductor Location Ref. No. Location
D401 D501 IC301 IC302 IC303 IC304 IC305 IC306 IC307 IC401 IC501 IC502 IC503 Q301 Q302 Q401 Q402 Q403 E-6 E-4 B-5 C-2 B-3 C-5 F-6 B-4 B-8 E-6 F-3 D-5 D-4 A-4 C-1 D-6 E-7 E-7
Note on Printed Wiring Boards: z * : Through hole. f * : internal component. * b : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: (Conductor Side) Parts face side: (Component Side) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
www..com
- 29 -
- 30 -
www..com
Note on Schematic Diagram: * All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. * All resistors are in and 1/4 W or less unless otherwise specified. f : internal component. * Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifies par une marque 0 sont critiques pour la securite. Ne les remplacer que par une piece por tant le numero specifie.
5-6. SCHEMATIC DIAGRAM - MECHANISM DECK Section -
* See page 39 for IC Block Diagrams and page 45 for Waveforms.
* U : B+ Line. * Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. * Voltages and waveforms are dc with respect to ground under no-signal conditions. no mark : MD : Impossible to measure * Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. * Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. * Circled numbers refer to waveforms. * Signal path. E : MD
MDX-C7900/C7900R
www..com
- 31 -
- 32 -
- 33 -
- 34 -
MDX-C7900/C7900R
www..com
Note on Schematic Diagram: * All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. * All resistors are in and 1/4 W or less unless otherwise specified. f * : internal component. * C : panel designation. * U : B+ Line. * H : adjustment for repair. * Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. * Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : FM ( ) : AM : LW < > : MD
* Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. * Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. * Circled numbers refer to waveforms. * Signal path. F : FM f : AM E : MD L : BUS AUDIO IN * Abbreviation CND : Canadian G : German
5-7. SCHEMATIC DIAGRAM - MAIN Section - * See page 3 for Type A/Type B Discrimination.
* See page 42 for IC Block Diagrams and page 45 for Waveforms.
www..com
- 35 -
- 36 -
- 37 -
- 38 -
www..com
MDX-C7900/C7900R
* Semiconductor Location (Component Side) Ref. No. Location Ref. No. Location
D3 D5 D200 D201 D202 D302 D303 D500 D501 D504 D505 D506 D507 D508 D600 D601 D602 D603 D701 D702 D800 D801 D802 D803 D900 D901 D902 D903 D904 D907 D909 D910 D911 D912 D913 D914 IC100 IC102 IC103 IC200 IC202 IC203 F-11 H-12 J-5 D-7 D-6 B-12 G-8 B-5 B-5 B-7 B-6 B-7 B-8 B-8 B-2 B-2 C-2 D-3 K-7 K-10 F-3 E-4 I-2 I-2 B-1 J-6 K-10 K-10 K-9 J-7 J-11 J-11 J-11 J-11 D-4 G-1 E-12 I-12 H-12 F-3 G-5 H-5 IC204 IC250 IC300 IC600 IC700 IC801 IC802 Q1 Q2 Q4 Q5 Q6 Q50 Q51 Q100 Q102 Q103 Q250 Q252 Q253 Q254 Q255 Q300 Q301 Q302 Q303 Q400 Q401 Q402 Q403 Q500 Q600 Q603 Q700 Q900 Q901 Q902 Q905 Q906 Q991 Q993 E-4 J-6 E-8 D-2 I-8 J-2 J-2 D-11 C-11 F-13 H-12 C-13 I-13 J-13 H-13 G-12 H-12 J-5 D-7 D-6 C-6 D-5 C-7 C-7 C-7 C-7 C-8 C-9 B-8 B-9 B-6 D-3 D-2 G-7 D-4 K-7 K-6 K-10 J-7 G-7 G-5
5-8. PRINTED WIRING BOARD - MAIN Section -
* See page 3 for Type A/Type B Discrimination.
* Semiconductor Location (Conductor Side) Ref. No. Location
D1 D4 D300 D301 D502 D503 D509 D510 D604 D700 D905 D906 D908 D916 IC201 IC500 IC800 IC900 Q101 Q251 Q601 Q701 Q903 Q904 Q992 C-2 C-4 B-5 B-3 B-12 B-8 B-7 B-7 C-13 H-7 K-5 K-5 K-7 K-12 E-10 A-7 E-13 F-13 H-4 I-9 D-13 K-9 H-13 H-12 G-5
Note on Printed Wiring Board: * X : parts extracted from the component side. f * : internal component. * b : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: (Conductor Side) Parts face side: (Component Side) * Abbreviation CND : Canadian
Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
www..com
- 39 -
- 40 -
- 41 -
- 42 -
MDX-C7900/C7900R
www..com
5-10.
* Semiconductor Location (Component Side) Ref. No. Location
D811 D812 D813 D814 D815 D816 D817 IC801 Q806 Q807 C-3 B-3 A-4 A-2 B-1 C-2 A-11 B-8 C-4 B-1
SCHEMATIC DIAGRAM - PANEL Section -
* See page 46 for Waveform.
5-9. PRINTED WIRING BOARD - PANEL Section -
* Semiconductor Location (Conductor Side) Ref. No. Location
D802 D803 D804 D806 D807 D808 D819 Q801 Q802 Q803 Q804 Q805 B-12 B-12 B-12 B-6 B-6 C-12 B-2 B-5 B-5 B-5 B-5 B-2
Note on Printed Wiring Board: * X : parts extracted from the component side. * b : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: (Conductor Side) Parts face side: (Component Side) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
www..com
Note on Schematic Diagram: * All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. * All resistors are in and 1/4 W or less unless otherwise specified. * C : panel designation. * U : B+ Line. * Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords.
* Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : FM (AMBER Illumination) ( ) : FM (GREEN Illumination) * Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. * Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. * Circled numbers refer to waveforms.
- 43 -
- 44 -
- 45 -
- 46 -
www..com
* IC Block Diagrams - SERVO Board - IC301 CXD2652AR
APCREF F0CNT TEST3 TEST2 TEST1 SRDR DVDD DCHG SPRD EFMO TRDR LDDR DVSS FRDR SFDR ADFG SPFD CKRF TFDR DTRF XLRF FFDR FGIN APC FS4
100 99 98 97 96 95
94 93
92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76
AUTO SEQUENCER
MNT0 1 MNT1 2 MNT2 3 MNT3 4 MONITOR CONTROL EACH BLOCK
SPINDLE SERVO
PWM GENERATOR
75 AUX2 74 TE 73 SE 72 AVSS 71 ADRB
ADIP DECODER SWDT 5 SCLK 6 XLAT 7 SRDT 8 SENS 9 XRST 10 SQSY 11 DQSY 12 RECP 13 SUBCODE PROCESSOR CPU I/F EACH BLOCK SERVO DSP A/D CONVERTER ANALOG MUX
70 ADRT 69 AVDD 68 ADIO 67 VC 66 AUX1 65 FE 64 ABCD 63 BOTM 62 PEAK 61 CLTV
PLL
60 FILO 59 FILI 58 PCO 57 PDO 56 AVSS
XINT 14 TX 15 OSCI 16 OSCO 17 XTSL 18 NC 19 DVSS 20 DIN 21 DOUT 22 CLOCK GENERATOR EACH BLOCK
SHOCK RESISTANT MEMORY CONTROLLER
EFM/ACIRC ENCODER/ DECODER
DIGITAL AUDIO I/F
SAMPLING RATE CONVERTER
COMP
55 RFI 54 BIAS 53 AVDD 52 ASYI 51 ASYO
ADDT 23 DADT 24 LRCK 25
ATRAC ENCODER/DECODER
ADDRESS/DATA BUS A00 - A11, D0 - D3
26 27 28
29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49
50
DVDD
DVSS
FS256
XRAS
XBCK
XCAS
www..com
- 47 -
MVCI
XWE
XOE
A03
A02
A01 A00
A10
A04
A05
A06
A07
A08
A11
A09
D1
D0
D2
D3
www..com
IC302
CXA2523R
COMPO COMPP MORFO RF AGC MORFI ADDC PEAK AGCI OPN OPO RFO RF
48
47
46
45 - + USROP
44
43 42 + - BPF3T
41
40 RF AGC
39
38 EQ
37
+ -
RFA1
USRC DET EQ
RFA2 I J 1 2 -1 - -2 - CFST - 1 - -2 GRV GRVA -2 -1 WBL HLPT -1 -2 PTGR 3T PEAK BOTTOM 3T
PEAK3T P-P WBL
TEMP 36 BOTM
VC
3
A
4 IVR
B
5 IVR
C
6 IVR
D
7 IVR
E
8 IVR
F
9 IVR
GSW IV PD 10
+ - + -
APC 11 APCREF 12 13
GND
TEMPI
TEMPR
SWDT
SCLK
EQADJ
VREF
F0CNT
www..com
- 48 -
XSTBY
3TADJ
XLAT
VCC
- + + - + - + - + - + - + -
CVB
PBH
35 ABCD 34 FE 33 AUX BPFC 32 ADFG 31 ADAGC
AA
+ + + +
ABCDA
BB
+ + - -
30 ADIN FEA
CC BPF22 - - + + DD WBL - + - + EFB TESW PTGR WBL ATA ADIP AGC
DET
29 ADFM
-1 -2 SEA
TG
28 SE 27 CSLED
EE
+ -
EE'
-1 -2 TEA
TG
26 TE
FF
+ - FBAL
FF'
WBL 3T EQ VI CONV 25 WBLADJ
AUXSW COMMAND
BGR VREF
SCRI - PARA DECODE
14
15
16
17
18
19
20
21
22 23
24
www..com
IC303
CAPA-
BH6511FS-E2
PGND2 PGND1 OUT2R OUT1R CAPA+ OUT2F OUT1F VM12 IN2R IN1R VM2 VM1 IN2F IN1F VDD
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
INTERFACE
AMP
AMP
AMP
AMP
INTERFACE
VDD
CHARGE PUMP. OSC
PREDRIVE
PREDRIVE
PREDRIVE
PREDRIVE
INTERFACE
AMP
AMP
AMP
AMP
INTERFACE
PSB
1
GND
2
VG
3
IN4R
4
IN4F
5
VM4
6
OUT4F
7
PGND4
8
OUT4R
9
VM34
10
OUT3R
11
PGND3
12
OUT3F
13
VM3
14
IN3F
15
IN3R
16
PSB
26 GND 25 D4 24 D3 23 XCAS 22 XOE 21 NC 20 NC 19 NC 18 A8 17 A7 16 A6 15 A5 14 A4
IC305
OUT1 1
BA6287F
8 GND
VM 2
7 OUT2
DRIVER TSD
DRIVER
VCC 3
CONTROL LOGIC
6 VREF
POWER SAVE FIN 4 5 RIN
IC307
MSM51V4400-70TS-K
D1 1 D2 2 XWE 3
CLOCK OSC
NC 5 NC 6 NC 7 A9 8 A0-A9 COLUMN DECODER
SENSE REFRESH AMP INPUT/OUTPUT CONTROL SWITCH
ADDRESS BUFFER
A1 10 A2 11 A3 12
A0-A9
ROW DECODER
MEMORY CELL (4194204 BIT)
www..com VDD 13
(4) OUTPUT BUFFER
A0 9
(4) INPUT BUFFER
XRAS 4
- 49 -
www..com
- MAIN Board - IC100 BU2624FV-E2
20 XOUT 19 VSS PHASE DET XIN 1 REFERENCE DIVIDER MAIN COUNT CE CK DA CD 2 4 5 6 IF COUNT CTL P0 7 14 P2 I/O CTL SHIFT REGISTER LATCH 15 AMIN PRESCALER 18 PD 17 VDD 16 FMIN
P1
9
20BIT COUNT
13 IFIN
P3 10
12 SD 11 P4
IC102 SAA6588T-118 (MDX-C7900R)
SCOUT LVIN VSSA MPX MAD PSWN
12 11 PAUSE DETECTOR
VDDA
VREF
CIN
20
19
18
17
16
15
14
MULTI PATH DETECTOR
POWER SUPPLY & RESET 57kHz 8th ORDER BAND-PASS FILTER SIGNAL QUALITY DECODER 4 CLOCK 5 4 CLOCK INTERFACE REGISTER DATA DATA
CLOCKED COMPARATOR
RDS/RDBS DEMODULATOR
RDS/RDBS DECODER
TEST CONTROL
OSCILLATOR & CLOCK
IIC BUS SLAVE TRANSCEIVER
12
3
4
5
6
7
8
9
OSCI
DAVN
VSSD
SDA
OSCO
MRO MPTH
www..com
VDDD
TCON
SCL
AFIN
13 10
- 50 -
www..com
IC200
REF
1 2 3 4 5 6 7 8
TC9246F-TP1
16
IC201
VDD
SM5852FS-E2
16 15 14 13 DB/DS MOD2 MOD1 OPT
LRCI 1 BCKI 2 DI 3
VAR. PHASE REF. COMPARATOR
INPUT INTERFACE
PD
LOCK
DIGITAL SIGNAL PROCESSOR
LOCK DETECTION CIRCUIT
15 14
CLK 4
S2
SYSTEM CLOCK
VDDA
12 VDD
VSS 5 RSTN 6 TESTN 7 MUTEN 8 SEQUENTIAL CONTROL MUTE CONTROL MODE CONTROL 11 LRCO 10 BCKO 9 DOUT
PROGRAMMABLE COUNTER
MICRO COMPUTER INTERFACE
AMPI
S1
OUTPUT INTERFACE
13
VCO
12
AMPO
M2
11
VSSA
M1
10
XI
CKO
XO
SELECTOR
VSS
9
IC202
XTI DGND VDD 1 2 3
PCM1717E-ST2
CLK CONTROL 20 XTO 19 CLKO
IC250
NJM2360AM (TE2)
CS 1 Q1 ES 2 CT 3 GND 4
Q2
Q
S R Ipk CT OSC
8 CD 7 SI 6 V+ 5 INVIN COMP
LRCIN 4 DIN BCKIN ZERO 5 6 7
INPUT INTERFACE
18 ML/MUTE MODE CONT ROL 17 MC/DM1 16 MD/DM0 15 RSTB 14 MODE
DIGITAL FILTER
VREF 1.25V
+ -
NOISE SHAPER 5LEVE DAC LOWPASS FILTER CMOS AMP 5LEVEL DAC LOWPASS FILTER CMOS AMP
D/C R
8
13 D/C L 12 VOUTL 11 VCC
IC600
BUS ON 1
BA8270F-E2
BUS ON SWITCH RESET SWITCH BATTERY SWITCH 14 VCC
VOUTR 9 AGND 10
RST 2
BATT 3
13 12 11 10
RST BUS ON CLK IN BU IN
CLK 4 VREF 5 DATA 6 GND 7
9 DATA IN 8 DATA OUT
www..com
- 51 -
www..com
IC300
LC75374E
LTOUT LSIN NC LVRIN LCOM NC LSB1 LT1 LT2 LT3 LSB2
23 22 LFIN + - + - - + - + + - 21 LFOUT
33
32
31 30
29
28 27 26 25 24
DECODER
LATCH
1
2
34
5
6 7 8 9 10
11
RVRIN
RCOM
RTOUT RSIN NC NC RSB1
IC800
BA3918-V3
REGULATOR
OVER VOLTAGE PROTECT + - + - + - + -
1
234
5
6
7
8
9
10
RSB2
RT1 RT2
RT3
11
12
MODE2 MODE1 STB
VDD
COM
AMP
www..com
- 52 -
GND
NC
VCC
ANT
AM
FM
+ -
R1 R2 R3 R4 RSELO
40 41 42 43 44
+ -
- +
- +
- +
VDD 39
- +
LSELO L4 L3 L2 L1
34 35 36 37 38
+ - + -
20 LROUT
19 VREF CONTROL 18 CE 17 DI 16 CL 15 VSS 14 RROUT
+ -
+ - SHIFT REGISTER + -
13 RFOUT 12 RFIN
www..com
* Waveforms - MECHANISM DECK Section -
1 IC302 wh (TE) (PLAY MODE) 6 IC501 ea (EXTAL) (PLAY MODE) 3 IC201 1 (LRCL) (PLAY MODE)
0.5 Vp-p
2.7 Vp-p
5.1 Vp-p
0.1 s 2 IC302 ef (FE) (PLAY MODE) 7 IC304 3 (IN) (PLAY MODE)
23 s 4 IC201 2 (BCKI) (PLAY MODE)
0.3 Vp-p
3.5 Vp-p
5.2 Vp-p
44 ns 3 IC302 ek (RF) (PLAY MODE)
354 ns 5 IC202 1 (XTI) (PLAY MODE)
1.2 Vp-p
3.3 Vp-p
- MAIN Section -
4 IC301 wg (LRCK) (PLAY MODE) 1 IC204 1 (IN) (PLAY MODE)
88 ns
6 IC202 4 (LRCK) (PLAY MODE)
3.5 Vp-p
4.5 Vp-p
5.1 Vp-p
23 s 5 IC301 wh (XBCK) (PLAY MODE)
23 s 2 IC204 3 (IN) (PLAY MODE)
23 s 7 IC202 6 (BCK) (PLAY MODE)
4.5 Vp-p
3.7 Vp-p
4.9 Vp-p
www..com
356 s
356 ns
472 ns
- 53 -
www..com
- PANEL Section -
8 IC102 5 (OSCI) (FM MODE) 1 IC801 w; (OSC IN)
3.8 Vp-p
2.1 Vp-p
230 ns 9 IC100 1 (XI) (RADIO MODE)
5.2 s
1.8 Vp-p
139 ns 0 IC700 od (X1)
5.6 Vp-p
272 ns qa IC700 ud (X1A)
5 Vp-p
31 s
www..com
- 54 -
www..com
5-11.
IC PIN FUNCTION DESCRIPTION
* SERVO BOARD IC301 CXD2652AR (DIGITAL SIGNAL PROCESSOR, DIGITAL SERVO PROCESSOR, EFM/ACIRC ENCODER/DECODER, SHOCK PROOF MEMORY CONTROLLER, ATRAC ENCODER/DECODER, 2M BIT D-RAM) Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 37 38 39 Pin Name MNT0 MNT1 MNT2 MNT3 SWDT SCLK XLAT SRDT SENS XRST SQSY DQSY RECP XINT TX OSCI OSCO XTSL RVDD RVSS DIN DOUT ADDT DADT LRCK XBCK FS256 DVDD A03 A02 A01 A00 A10 A04 A05 A07 A08 A11 I/O O O O O I I I O (3) O (3) I O O I O I I O I -- -- I O I O O O O -- O O O O O O O Address signal output to the D-RAM (IC307) O O O Address signal output to the external D-RAM Not used (open) Address signal output to the external D-RAM Not used (open) Address signal output to the D-RAM (IC307) Function Focus OK signal output to the MD mechanism controller (IC501) "H" is output when focus is on ("L": NG) Track jump detection signal output to the MD mechanism controller (IC501) Monitor 2 signal output to the MD mechanism controller (IC501) Monitor 3 signal output to the MD mechanism controller (IC501) Writing serial data signal input from the MD mechanism controller (IC501) Serial data transfer clock signal input from the MD mechanism controller (IC501) Serial data latch pulse signal input from the MD mechanism controller (IC501) Reading serial data signal output to the MD mechanism controller (IC501) Internal status (SENSE) output to the MD mechanism controller (IC501) Reset signal input from the MD mechanism controller (IC501) "L": reset Subcode Q sync (SCOR) output to the MD mechanism controller (IC501) "L" is output every 13.3 msec Almost all, "H" is output Digital In U-bit CD format subcode Q sync (SCOR) output terminal "L" is output every 13.3 msec Almost all, "H" is output Not used (open) Laser power selection signal input terminal "H": recording mode, "L": playback mode (fixed at "L" in this set) Interrupt status output to the MD mechanism controller (IC501) Recording data output enable signal input terminal Writing data transmission timing input (Also serves as the magnetic head on/off output) Not used (fixed at "L") System clock signal (512Fs=22.5792 MHz) input from the oscillator circuit System clock signal (512Fs=22.5792 MHz) output terminal Not used (open) Input terminal for the system clock frequency setting "L": 45.1584 MHz, "H": 22.5792 MHz (fixed at "H" in this set) Power supply terminal (+3.3V) (digital system) Ground terminal (digital system) Digital audio signal input terminal when recording mode (for optical in) Digital audio signal output terminal when playback mode (for optical out) Recording data input terminal Playback data output terminal Not used (fixed at "L") Not used (open) Not used (open) Not used (open) Not used (fixed at "L") Not used (open)
L/R sampling clock signal (44.1 kHz) output terminal Bit clock signal (2.8224 MHz) output terminal Power supply terminal (+3.3V) (digital system)
Clock signal (11.2896 MHz) output to the PCM1717E (IC202)
www..com 36 A06 O
- 55 -
www..com
Pin No. 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86
Pin Name DVSS XOE XCAS A09 XRAS XWE D1 D0 D2 D3 MVCI ASYO ASYI AVDD BIAS RFI AVSS PDO PCO FILI FILO CLTV PEAK BOTM ABCD FE AUX1 VC ADIO AVDD ADRT ADRB AVSS SE TE AUX2 DCHG APC ADFG F0CNT XLRF CKRF DTRF APCREF LDDR TRDR TFDR
I/O -- O O O O O I/O I/O I/O I/O I O I (A) -- I (A) I (A) -- O (3) O (3) I (A) I (A) I (A) I (A) I (A) I (A) I (A) I (A) -- I (A) I (A) -- I (A) I (A) I (A) I (A) I (A) I O O O O O Ground terminal (digital system)
Function Output enable signal output to the D-RAM (IC307) "L" active Column address strobe signal output to the D-RAM (IC307) "L" active Address signal output to the external D-RAM Not used (open) Row address strobe signal output to the D-RAM (IC307) "L" active Write enable signal output to the D-RAM (IC307) "L" active
Two-way data bus with the D-RAM (IC307)
Digital in PLL oscillation input from the external VCO Playback EFM full-swing output terminal
Not used (fixed at "L")
Playback EFM asymmetry comparator voltage input terminal Power supply terminal (+3.3V) (analog system) Playback EFM asymmetry circuit constant current input terminal Playback EFM RF signal input from the CXA2523R (IC302) Ground terminal (analog system) Phase comparison output for clock playback analog PLL of the playback EFM Filter input for master clock of the recording/playback master PLL Internal VCO control voltage input of the recording/playback master PLL Light amount signal (RF/ABCD) peak hold input from the CXA2523R (IC302) Light amount signal (RF/ABCD) bottom hold input from the CXA2523R (IC302) Light amount signal (ABCD) input from the CXA2523R (IC302) Focus error signal input from the CXA2523R (IC302) Auxiliary signal (I3 signal/temperature signal) input terminal Not used (fixed at "H") Middle point voltage (+1.65V) input from the CXA2523R (IC302) Not used (open) Power supply terminal (+3.3V) (analog system) A/D converter operational range upper limit voltage input terminal (fixed at "H" in this set) A/D converter operational range lower limit voltage input terminal (fixed at "L" in this set) Ground terminal (analog system) Sled error signal input from the CXA2523R (IC302) Tracking error signal input from the CXA2523R (IC302) Auxiliary signal input terminal Light amount signal input from the CXA2523R (IC302) Not used (fixed at "L") Connected to the +3.3V power supply Error signal input for the laser automatic power control Filter f0 control signal output terminal Not used (open) Not used (open) Not used (open) ADIP duplex FM signal (22.05 kHz 1 kHz) input from the CXA2523R (IC302) Serial data latch pulse signal output terminal Writing serial data output terminal Not used (open) Phase comparison output for master clock of the recording/playback EFM master PLL
O (A) Filter output for master clock of the recording/playback master PLL
O (A) Monitor output of the A/D converter input signal
Serial data transfer clock signal output terminal
Not used (open)
www..com
O O O
Control signal output to the reference voltage generator circuit for the laser automatic power control PWM signal output for the laser automatic power control Not used (open)
Tracking servo drive PWM signal (-) output to the BH6511FS (IC303) Tracking servo drive PWM signal (+) output to the BH6511FS (IC303)
- 56 -
www..com
Pin No. 87 88 89 90 91 92 93 94 95 96 97 98 99 100
Pin Name DVDD FFDR FRDR FS4 SRDR SFDR SPRD SPFD FGIN TEST1 TEST2 TEST3 DVSS EFMO
I/O -- O O O O O O O I I I I -- O Ground terminal (digital system) Input terminal for the test (fixed at "L")
Function Power supply terminal (+3.3V) (digital system) Focus servo drive PWM signal (+) output to the BH6511FS (IC303) Focus servo drive PWM signal (-) output to the BH6511FS (IC303) Clock signal (176.4 kHz) output terminal (X'tal system) Not used (open) Sled servo drive PWM signal (-) output to the BH6511FS (IC303) Sled servo drive PWM signal (+) output to the BH6511FS (IC303) Spindle servo drive PWM signal (-) output to the BH6511FS (IC303) Spindle servo drive PWM signal (+) output to the BH6511FS (IC303) Not used (fixed at "L")
EFM signal output terminal when recording mode Not used (open)
* I (A) for analog input, O (3) for 3-state output, and O (A) for analog output in the column I/O.
www..com
- 57 -
www..com
* SERVO BOARD IC302 CXA2523R (RF AMP, FOCUS/TRACKING ERROR AMP) Pin No. 1 2 3 4 to 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 Pin Name I J VC A to F PD APC APCREF GND TEMPI TEMPR SWDT SCLK XLAT XSTBY F0CNT VREF EQADJ 3TADJ VCC WBLADJ TE CSLED SE ADFM ADIN ADAGC ADFG AUX FE ABCD BOTM PEAK RF RFAGC AGCI COMPO COMPP ADDC OPO OPN RFO MORFI I/O I I O I I O I -- I O I I I I I O I I -- I O I O O I I O O O O O O O I I O I I O I O I Function I-V converted RF signal I input from the optical pick-up block detector I-V converted RF signal J input from the optical pick-up block detector Middle point voltage (+1.65V) generation output terminal Signal input from the optical pick-up detector Light amount monitor input from the optical pick-up block laser diode Laser amplifier output terminal to the automatic power control circuit Reference voltage input terminal for setting laser power Ground terminal Connected to the temperature sensor Not used (open) Output terminal for a temperature sensor reference voltage Not used (open) Writing serial data input from the MD mechanism controller (IC501) Serial data transfer clock signal input from the MD mechanism controller (IC501) Serial data latch pulse signal input from the MD mechanism controller (IC501) Standby signal input terminal "L": standby (fixed at "H" in this set) Center frequency control voltage input terminal of internal circuit (BPF22, BPF3T, EQ) input terminal Reference voltage output terminal Not used (open) Center frequency setting terminal for the internal circuit (EQ) Center frequency setting terminal for the internal circuit (BPF3T) Power supply terminal (+3.3V) Center frequency setting terminal for the internal circuit (BPF22) Tracking error signal output to the CXD2652AR (IC301) Connected to the external capacitor for low-pass filter of the sled error signal Sled error signal output to the CXD2652AR (IC301) FM signal output of the ADIP Receives a ADIP FM signal in AC coupling Connected to the external capacitor for ADIP AGC ADIP duplex signal (22.05 kHz 1 kHz) output to the CXD2652AR (IC301) Auxiliary signal (I3 signal/temperature signal) output terminal Not used (open) Focus error signal output to the CXD2652AR (IC301) Light amount signal (ABCD) output to the CXD2652AR (IC301) Light amount signal (RF/ABCD) bottom hold output to the CXD2652AR (IC301) Light amount signal (RF/ABCD) peak hold output to the CXD2652AR (IC301) Playback EFM RF signal output to the CXD2652AR (IC301) Connected to the external capacitor for RF auto gain control circuit Receives a RF signal in AC coupling User comparator output terminal Not used (open) User comparator input terminal Not used (fixed at "L") Connected to the external capacitor for cutting the low band of the ADIP amplifier User operational amplifier output terminal Not used (open) User operational amplifier inversion input terminal Not used (fixed at "L") RF signal output terminal Receives a MO RF signal in AC coupling
48 www..com signal output terminal MORFO O MO RF
- 58 -
www..com
* SERVO BOARD IC501 CXP84340-089Q (MD MECHANISM CONTROLLER) Pin No. 1 to 5 6 7 8, 9 10 11 12 13 14 to 17 18 19 20 21 22 23 24, 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 45 46 Pin Name TIN3 to TIN7 LOAD EJECT NCO MDMON E-SW AG-OK ADJ-OK NCO DFCTSEL DPLLSEL EMPHSEL LOCK NCO 2M/4M NCO MNT0 MNT1 MNT2 MNT3 RESET EXTAL XTAL VSS TX TEX AVSS AVREF INIT TEMP ACNT DO-SEL EE-CS EE-CKO MD-SO LINKOFF I/O I/O O O O O I O O O I I I O O I O I I I I I O I -- O I -- I I I I I O O O O Function Input of the 4x8 matrix test keys ("L" is always output, except in test mode) Loading motor control signal output to the motor driver (IC305) Loading motor control signal output to the motor driver (IC305) Not used (open) Power supply on/off control signal output of the MD mechanism deck section main power supply and loading motor drive (IC305) power supply "H": power on Inputs the disc loading completion detect switch (S902) detection signal "L": When completed of the disc loading operation Output of aging status in test mode "H": aging completed, "L": under aging Not used (open) Output of status when aging completed in test mode "H": aging OK, "L": aging NG Not used (open) Not used (open) Select whether defect function is used for the CXD2652AR (IC301) "H": not used this function, "L": used this function (fixed at "H" in this set) Select whether digital pll function is used for the CXD2652AR (IC301) "H": not used this function, "L": used this function (fixed at "H" in this set) Select whether emphasis signal output from pin or unilink data "H": output from pin only, "L": outputs from both pin and unilink data Not used (open) Select whether D-RAM capacitance 2M bit or 4M bit "H": 2M bit (internal D-RAM of CXD2652AR), "L": 4M bit (external D-RAM) (fixed at "L" in this set) Not used (open) Focus OK signal input from the CXD2652AR (IC301) "H" is input when focus is on ("L": NG) Track jump detection signal input from the CXD2652AR (IC301) Monitor 2 signal input from the CXD2652AR (IC301) Monitor 3 signal input from the CXD2652AR (IC301) System reset signal input from the master controller (IC700), reset signal generator (IC801) and reset switch (S900) "L": reset For several hundreds msec. after the power supply rises, "L" is input, then it changes to "H" Main system clock output terminal (10 MHz) Main system clock input terminal (10 MHz) Ground terminal Sub system clock output terminal (32.768 kHz) Sub system clock input terminal (32.768 kHz) Ground terminal (for A/D converter) Reference voltage input terminal (+5V) (for A/D converter) Initial reset signal input terminal (A/D input) (fixed at "H") Temperature sensor (TH501) input terminal (A/D input) Select the number of load/eject aging times (A/D input) 0H - 54H (30 times), 55H - OA9H (20 times), OAAH - OFFH (10 times) Select the digital output bits (A/D input) Chip select signal output to the external EEPROM device Two way data bus with the external EEPROM device Not used (open) Not used (open) Serial data transfer clock signal output to the external EEPROM device Not used (open) Not used (open) Not used (fixed at "L") Not used (open) *1 *1 Not used (open)
Mini-disc lock detection signal output to the master controller (IC700) "H": lock
www..com 44 EE-SIO I/O
Writing serial data signal output to the CXD2652AR (IC301) and CXA2523R (IC302) Unilink on/off control signal output for the SONY bus "H": link off, "L": link on
- 59 -
www..com
Pin No. 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 to 77 78 to 80
Pin Name UNIREQ UNCKI UNISI UNISO MD-CKO MD-SI NCO SENS CC-XINT LIMIT-IN EJT-KEY ERROR-PWM MD-RST BU-IN BUS-ON SQSY C-SW MD-LAT MD-ON DEEMP A-MUTE NCO TSTCKO TSTSO TSTMOD VCC NC
TOUT0 to TOUT3
I/O O I I O O I O I I I I O O I I I I O O O O O O O I -- -- O I/O
Function Data request signal output terminal (for SONY bus) "H": request on Serial data input from the SONY bus interface (IC600) Serial data output to the SONY bus interface (IC600) Serial data transfer clock signal output to the CXD2652AR (IC301) and CXA2523R (IC302) Reading serial data signal input from the CXD2652AR (IC301) Not used (open) Internal status (SENSE) input from the CXD2652AR (IC301) Interrupt status input from the CXD2652AR (IC301) Detection input from the sled limit-in detect switch (S903) The optical pick-up is inner position when "L" Eject request signal input terminal "L": eject on Not used (fixed at "H") Not used (open) Not used (open) Serial data transfer clock signal input from the master controller (IC700) (for SONY bus)
PWM error monitor output terminal (C1and ATER is output when test mode)
Reset signal output to the CXD2652AR (IC301) and BH6511FS (IC303) "L": reset Battery detect signal input from the SONY bus interface (IC600) and battery check circuit "H": battery on SONY bus on/off control signal input from the master controller (IC700) "L": bus on Subcode Q sync (SCOR) input from the CXD2652AR (IC301) "L" is input every 13.3 msec Almost all, "H" is input Inputs the disc loading start or disc eject completion detect switch (S901) detection signal "L": When start or eject completed of the disc loading operation Serial data latch pulse signal output to the CXD2652AR (IC301) and CXA2523R (IC302) Power supply on/off control signal output of the MD mechanism deck section main power supply "H": power on Emphasis on/off control signal output terminal "H": emphasis on Audio muting on/off control signal output terminal Not used (open) Output of clock signal for the test mode display Output of data for the test mode display Power supply terminal (+5V) Not used (fixed at "H") Output of the 4x8 matrix test keys Not used (open) Not used (open) Input of the 4x8 matrix test keys ("L" is always output, except in test mode) Not used (open) Not used (open) Not used Not used
Setting terminal for the test mode "L": test mode, "H": normal mode
TIN0 to TIN2
*1 Loading motor (M903) control Operation Terminal LOAD (pin 6) EJECT (pin 7) IN "H" "L" OUT "L" "H" BRAKE "H" "H" STOP "L" "L"
www..com
- 60 -
www..com
* MAIN BOARD IC700 (MASTER CONTROLLER)
MDX-C7900 Type A Type B MB90574PFV-G-114-BND MB90574PFV-G-114 MDX-C7900R MB90574PFV-G-113-BND MB90574PFV-G-113
Pin No. 1 to 7 8 9 10 11 12 13 14 15 16 17 to 19 20 21 22 23 to 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46
Pin Name NC VCC PLL SI PLL SO PLL CKO NOSE SW LCD SO LCD CKO BEEP DBMOD2 NC UNI SI UNI SO UNI CKO NC VOL SO VOL CKO DSTSEL0 SYSRET DSTSEL1 DMOD1 TESTIN VSS C NC BUS ON AD ON DVCC DVSS LCDANG VOL CE AVCC AVRH AVRL AVSS KEY IN0
I/O O -- I O O I O O O O O I O O O O O I O I O I -- -- O O O -- -- O O -- I I -- I Not used (open) Power supply terminal (+5V)
Function
PLL serial data input from the FM/AM PLL (IC100) PLL serial data output to the FM/AM PLL (IC100) PLL serial data transfer clock signal output to the FM/AM PLL (IC100) Detects the removal of the attaching and removing type front panel block "L": attaching Serial data output to the liquid crystal display driver (IC801) Serial data transfer clock signal output to the liquid crystal display driver (IC801) Beep sound drive signal output terminal D-BASS mode control signal output to the SM5852ES (IC201) Not used (open) Serial data input from the SONY bus interface (IC600) Serial data output to the SONY bus interface (IC600) Serial data transfer clock signal output to the MD mechanism controller (IC501) and SONY bus interface (IC600) Not used (open) Serial data output to the electrical volume (IC300) Serial data transfer clock signal output to the electrical volume (IC300) Destination setting terminal (US, Canadian models: fixed at "H", E model and MDX-C7900R: fixed at "L") System reset signal output to the MD mechanism controller (IC501) and SONY bus interface (IC600) "L": reset Destination setting terminal (US, Canadian models and MDX-C7900R: fixed at "L", E model: fixed at "H") D-BASS mode control signal output to the SM5852ES (IC201) Setting terminal for the test mode "L": test mode (normally fixed at "H") Ground terminal Connected to capacitor (for coupling) Not used (open) Bus on/off control signal output to the MD mechanism controller (IC501) and SONY bus interface (IC600) "L": bus on Power supply on/off control signal output for the A/D converter "L": power on Power supply terminal (+5V) (for D/A converter) Ground terminal (for D/A converter) Output signal for the LCD view angle adjustment "H": When front panel is full open Chip enable signal output to the electrical volume (IC300) Power supply terminal (+5V) (for A/D converter) Reference voltage (+5V) input terminal (for A/D converter) Reference voltage (0V) input terminal (for A/D converter) Ground terminal (for A/D converter) Key input terminal (A/D input) OFF, SOURCE, SEEK/AMS > M + . m - , SOUND, SHIFT, 1, 2, 3, 4 keys input (LSW801 to LSW804 and LSW806 to LSW811)
www..com
- 61 -
www..com
Pin No.
Pin Name
I/O
Function Key input terminal (A/D input) MDX-C7900: Z, LIST, DSPL, 10, 9, 8, 7, 6, 5 keys input (LSW812 and LSW814 to LSW821) MDX-C7900R: Z, DSPL, LIST PTY, AF/TA, 10, 9, 8, 7, 6, 5 keys input (LSW812 to LSW821) Key input terminal (A/D input) Not used (fixed at "L") Rotary remote commander shift key A/D input terminal D-BASS switch (LSW805) input terminal (A/D input) Not used (fixed at "L") Multi path input from the RDS decoder (IC102) Used for the MDX-C7900R only FM and AM (MW/LW) signal meter voltage detection input from the FM/AM tuner unit (TU1) Power supply terminal (+5V) Muting control signal output to the power amplifier (IC500) "H": muting on Standby control signal output to the power amplifier (IC500) "L": standby, "H": amp on Illuminate line detect signal input for the auto dimmer control Dimmer is present at input of "L" Mini-disc lock detection signal input from the MD mechanism controller (IC501) "H": lock Emphasis control signal output to the D/A converter (IC202) "H": emphasis on Audio line muting on/off control signal output terminal "H": muting on RDS AF playing attenuate signal output terminal Not used (open) Tuner signal (FM and AM) muting on/off control signal output "H": muting on Ground terminal Accessory detect signal input terminal "L": accessory on RDS AF seek control signal output terminal Used for the MDX-C7900R only Not used (open) Data transmit completed detect signal input from the RDS decoder (IC102) Used for the MDX-C7900R only Not used (open) Serial data input from the RDS decoder (IC102) Used for the MDX-C7900R only Serial data transfer clock signal input from the RDS decoder (IC102) Used for the MDX-C7900R only Rotary remote commander shift key A/D input terminal Sub system clock output terminal (32 kHz) Sub system clock input terminal (32 kHz) Not used (open) Battery detect signal input from the SONY bus interface (IC600) and battery check circuit "H": battery on Not used (open) Input of acknowledge signal for the key entry Acknowledge signal is input to accept function and eject keys in the power off status On at input of "H" Telephone muting signal input terminal At input of "L", the signal is attenuated by -20 dB Input of FM stereo detection signal from FM/AM tuner unit (TU1), and output of forced monaural control signal to FM/AM tuner unit (TU1) (Commonly used for stereo display input and forced monaural output) FM stereo detection at input of "L", forced monaural at output of "L" Seek control signal output to the FM/AM tuner unit (TU1) (AM mode: used for IF count output, SD request, AGC cut etc., FM mode: used for SEEK, BTM, AF playing SD speed up etc.)
47
KEY IN1
I
48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68, 69 70 71 72 73 74 75 76 77, 78 79 80
KEY IN2 RC IN0 D-BASS IN NC MPDH (MTP)
S METER (VSM)
I I I I I I -- O O I I O O O O -- I O O I O I I I O I O I O I I
VCC AMP ATT AMP ON ILL IN LOCK IN EMPH ON AU ATT AF ATT TU ATT VSS ACC IN AF SEEK NC DAVN NC RDS SI RDS CKI RC IN1 X1A X0A NC BU IN NC KEYACK TEL ATT
81
ST IN/MONO
I/O
82
SEEKOUT
O
Station 83 www..com detector detect input from the FM/AM tuner unit (TU1) SD IN I Stop level for SEEK, BTM, etc. is determined SD is present at input of "H" 84 NC (MONO) I Not used (open)
- 62 -
www..com
Pin No. 85 86 87 88 89 90 91 92 93 94 95 96 97 to 99 100 101 102 103 104 105 106 107
Pin Name PLL CE HSTX MD2 MD1 MD0 RESET VSS X0 X1 VCC PW SEL POL MONO NC BAND (9K-10K) NC RAMBU NC LCD CE FLASH W REIN0 REIN1 LAMP ON (ILL ON) PW ON FM ON TUN ON NC VSS NC
I/O O I I I I I -- I O -- I I O I O I O O I I I Hardware standby input terminal
Function PLL serial chip enable output to the FM/AM PLL (IC100) Not used (open) Mode selection input terminal (fixed at "L") Mode selection input terminal (fixed at "H") Mode selection input terminal (fixed at "H") System reset signal input from the reset signal generator (IC801) and reset switch (S900) "L" is input for several 100 msec after power on, then it changes to "H" Ground terminal Main system clock input terminal (3.68 MHz) Main system clock output terminal (3.68 MHz) Power supply terminal (+5V) Power select switch (S700) input terminal "L": on (operation mode), "H": off (halt mode) Polar monaural detection signal input terminal Not used (open) Frequency select switch (S701) input terminal "H": MW 9k step/FM 50k step, "L": MW10k step/FM 200k step Used for the E model only Not used (open) Internal RAM reset detection signal input from the RN5VD23AA (IC802) Input terminal to check that RAM data are not destroyed due to low voltage This checking is made within 100 msec after reset Not used (open) Chip enable output to the liquid crystal display driver (IC801) Fixed at "H" in this set Rotary encoder (EN801) input for volume/bass/treble/balance/fader control Rotary encoder (EN801) input for volume/bass/treble/balance/fader control Power supply on/off control signal output terminal at the illumination and liquid crystal display driver (IC801) "H": power on At power select switch (S700) on mode: "H" output at the accessory on At power select switch (S700) off mode: "H" output at the power on Main system power supply on/off control signal output to the BA3918 (IC800) "H": power on FM system power supply on/off control signal output to the BA3918 (IC800) "H": FM on Tuner system power supply on/off control signal output to the BA3918 (IC800) "H": tuner on Not used (open) Ground terminal Not used (open) Not used (open)
108
O
109 110 111
112 to 118
O O O O -- O
119 120
www..com
- 63 -
www..com
SECTION 6 EXPLODED VIEWS
NOTE: * -XX and -X mean standardized parts, so they may have some difference from the original one. * Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE) . . . (RED) Parts Color Cabinet's Color * Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. * The mechanical parts with no reference number in the exploded views are not supplied. * Hardware (# mark) list and accessories and packing materials are given in the last of the electrical parts list. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifies par une marque 0 sont critiquens pour la securite. Ne les remplacer que par une piece portant le nemero specifie.
(1) GENERAL SECTION
12
MG-164KT-138
11 14 7 9
#3 F1
#3
10 6
17 8
#2
16
5 4 3 15 13
C7900
2
#2
#1
#2
1
Front panel section
Ref. No. 1 1 2 3 4 * * * * 5 6 6 6 Part No. 3-919-344-51 3-919-344-61 3-919-343-01 3-023-606-01 X-3367-636-1 X-3373-358-1 A-3294-393-A A-3294-394-A A-3294-410-A Description DOOR (MD) (C7900) DOOR (MD) (C7900R) SPRING (DOOR), TORSION PANEL, SUB LOCK ASSY Remark Ref. No. *9 10 11 * 12 13 13 14 * 15 * 16 * 17 F1 Part No. 3-023-604-01 3-376-464-11 3-932-860-01 X-3373-362-1 1-776-207-71 Description
13
C7900R
Remark
HEAT SINK SCREW (+PTT 2.6X6), GROUND POINT SCREW (2.6X4) (C TIGHT), +PTT COVER ASSY CORD (WITH CONNECTOR) (POWER) (C7900)
www..com
3-022-317-01 BRACKET (AMP) 3-011-078-01 BRACKET (POWER IC)
*6 *7 *8
CHASSIS ASSY MAIN BOARD, COMPLETE (C7900R: AEP, UK) MAIN BOARD, COMPLETE (C7900R: German) MAIN BOARD, COMPLETE (C7900: US, Canadian) A-3294-412-A MAIN BOARD, COMPLETE (C7900: E)
1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER) (C7900R) 3-011-999-01 CUSHION (MD) 3-014-156-01 SHEET (INSULATING) 3-355-209-01 PLATE (B), GROUND 3-937-122-01 HEAT SINK 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A)
- 64 -
www..com
Ver 1.1
(2) FRONT PANEL SECTION
68
not suplied (KEY board)
67 58 57 56 55 63 59 60 61
LCD801
66 65 64
#4
54 53 62
C7900
69
52
70
C7900R
51 70
Ref. No. 51 52 52 53 54 55 56 57 57 58
Part No.
Description
Remark
Ref. No. 61 62 * 63 * 64 * 65 * 66 * 67 68 69 70
Part No. 3-023-618-01 3-023-619-01 3-023-610-01 3-023-621-01 3-023-624-01 3-023-609-01 3-023-608-01 3-023-605-01 3-023-625-01 3-023-622-01
Description PLATE (L), LIGHT GUIDE PLATE (R), LIGHT GUIDE PLATE (LCD), GROUND SHEET (LCD) ILLUMINATOR (LCD)
Remark
3-023-611-01 BUTTON (10KEY) (OFF. SHIFT. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10) X-3375-315-1 PANEL ASSY, FRONT (C7900) X-3375-409-1 PANEL ASSY, FRONT (C7900R) 3-023-617-01 BUTTON (RELEASE) 3-008-667-01 SPRING (RELEASE) 3-023-626-01 3-023-612-01 3-023-613-01 3-023-613-31 3-023-615-01 BUTTON (SOURCE) KNOB (VOL) KNOB (AMS) (C7900) KNOB (AMS) (C7900R) RING, LIGHT GUIDE
PLATE (LCD), LIGHT GUIDE HOLDER (LCD) PANEL, BACK KNOB (D) BUTTON (EJ) (Z. PTY. AF/TA. DSPL) (C7900R)
www..com 59 3-023-629-01 BUTTON (MODE)
60 3-023-616-01 BUTTON (SOUND)
70 3-023-627-01 BUTTON (EJ) (Z. LIST. DSPL) (C7900) LCD801 1-803-111-11 DISPLAY PANEL, LIQUID CRYSTAL
- 65 -
www..com
(3) MECHANISM DECK SECTION-1 (MG-164KT-138)
112
#5
113 109 111
#6
114 108 115
107
110
106
116 117
118 105 104 113
#6
111 103 105 103 104 102
101
#5
Ref. No. * 101 * 102 103 104 105 * 106 107 108 * 109
Part No. A-3313-612-A X-3369-440-1 3-919-296-01 3-921-111-01 3-919-273-01
Description SERVO BOARD, COMPLE CHASSIS ASSY, MD SPRING (FL), TENSION SPRING (FL2), TENSION DAMPER, OIL
Remark
Ref. No. * 110 111 * 112 113 * 114 115 116 * 117 * 118
Part No. 3-919-280-01 3-919-281-01 X-3369-441-1 3-342-940-01 X-3369-445-1 3-919-274-01 3-925-034-01 X-3369-443-1 3-919-279-01
Description LEVER (LOCK R) SPRING (CHKG) COVER ASSY, MD WASHER (M) LEVER (LE) ASSY SPRING (LE) ROLLER (GLE) ARM ASSY, CHUCKING LEVER (LOCK L)
Remark
X-3369-444-1 HOLDER ASSY 3-919-319-01 SPRING (HOLDER) www..com 3-919-320-01 SPRING (SUB HOLDER) 3-919-436-01 CUSHION (EJ)
- 66 -
www..com
(4) MECHANISM DECK SECTION-2 (MG-164KT-138)
158 157
161 160 179 161
162 177 161 163 164
#6
166
156
159
#10
155
#10
168 167
M903
M901
153 154
#9 #7 #9
170
176 172 171
#8 M902
173
#8
#7
175 169
152
151 174
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifies par une marque 0 sont critiques pour la securite. Ne les remplacer que par une piece portant le nemero specifie. Remark
178
Ref. No. 151 152 * 153 * 154 * 155 156 157 158 159 160
Part No. 1-654-693-11 A-3309-892-A 3-919-297-01 3-919-284-01 X-3369-442-1 3-919-339-01 3-919-317-01 4-926-562-01 3-919-313-01 3-919-316-01
Description SENSOR FLEXIBLE BOARD SENSOR BOARD, COMPLETE RETAINER (SP) BASE (SL) CHASSIS (OP) ASSY SPRING (GLE) GEAR (LE) WASHER, STOPPER WHEEL, WORM GEAR (R)
Remark
Ref. No. * 168 0 169 170 * 171 * 172 173 * 174 * 175 176 177 178 179 M901 M902 M903
Part No. 3-919-312-01 8-583-037-02 X-3373-213-1 3-919-294-01 3-919-293-01 3-010-091-01 3-920-537-01 3-919-283-01 3-703-816-32 3-924-721-01 2-626-617-01 3-701-437-01 A-3301-407-A A-3291-190-A A-3291-191-A
Description BRACKET (MOTOR) OPTICAL PICK-UP KMS-241A/J2RP SCREW ASSY, FEED BEARING (SL) SHAFT (SL) SPRING (SL FEED) SHAFT (SL2) BRACKET (SL) SCREW (M1.4X1.6), SPECIAL HEAD SPRING (B-T) SCREW (2X8) WASHER MOTOR ASSY, SP (SPINDLE) MOTOR ASSY, SL (SLED) MOTOR ASSY, LO (LOADING)
161 3-342-940-01 WASHER (M) www..com 162 3-919-315-01 GEAR (S) 163 164 166 167 3-919-314-01 GEAR (F) X-3369-446-1 LEVER (S) ASSY 3-919-282-01 SPRING (RACK), TENSION X-3369-447-1 RACK ASSY
- 67 -
www..com
KEY
SECTION 7 ELECTRICAL PARTS LIST
* Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. * SEMICONDUCTORS In each case, u: , for example: uA. . : A. . uPA. . : PA. . uPB. . : PB. . uPC. . : PC. . uPD. . : PD. . * CAPACITORS uF: F * COILS uH: H The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifies par une marque 0 sont critiquens pour la securite. Ne les remplacer que par une piece portant le nemero specifie. When indicating parts by reference number, please include the board.
NOTE: * Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. * -XX and -X mean standardized parts, so they may have some difference from the original one. * RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable * Abbreviation Type A: See page 3 for Type A/B Discrimination. Type B: See page 3 for Type A/B Discrimination.
Ref. No.
Part No.
Description KEY BOARD **********
Remark
Ref. No.
Part No.
Description < IC >
Remark
IC801 * * * * * 3-023-608-01 3-023-609-01 3-023-610-01 3-023-621-01 3-023-624-01 HOLDER (LCD) PLATE (LCD), LIGHT GUIDE PLATE (LCD), GROUND SHEET (LCD) ILLUMINATOR (LCD) < CAPACITOR > C802 C803 C804 C805 C806 C811 C812 C813 C814 C815 1-163-809-11 1-164-489-11 1-164-489-11 1-164-489-11 1-163-809-11 1-163-009-11 1-163-009-11 1-163-009-11 1-163-009-11 1-163-009-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP < CONNECTOR > CNP801 1-764-423-11 PIN, CONNECTOR 12P < DIODE > D802 D803 D804 D806 D807 D808 D811 D812 D813 D814 D815 D816 D817 D819 8-719-056-83 8-719-056-83 8-719-056-83 8-719-977-00 8-719-977-00 8-719-978-69 8-719-987-45 8-719-987-45 8-719-987-45 8-719-987-45 8-719-987-45 8-719-987-45 8-719-987-45 8-719-977-00 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE UDZ-TE-17-6.8B UDZ-TE-17-6.8B UDZ-TE-17-6.8B DTZ5.1C DTZ5.1C DTZ-TT11-16B CL-155Y/PG-CD (ILLUMINATION) CL-155Y/PG-CD (ILLUMINATION) CL-155Y/PG-CD (MD WINDOW) CL-155Y/PG-CD (ILLUMINATION) CL-155Y/PG-CD (ILLUMINATION) CL-155Y/PG-CD (ILLUMINATION) CL-155Y/PG-CD (MD WINDOW) DTZ5.1C 0.047uF 0.22uF 0.22uF 0.22uF 0.047uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 25V 16V 16V 16V 25V 50V 50V 50V 50V 50V LSW801 LSW802 LSW803 LSW804 LSW805 LSW806 LSW807 LSW808 LSW809 LSW810
8-759-496-75 IC uPD16432BGC-018-9EU < LIQUID CRYSTAL DISPLAY >
LCD801 1-803-111-11 DISPLAY PANEL, LIQUID CRYSTAL < SWITCH > 1-762-620-11 1-762-620-11 1-771-290-11 1-762-620-11 1-762-937-11 1-762-620-11 1-762-620-11 1-762-620-11 1-762-620-11 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(OFF) SWITCH, KEY BOARD (WITH LED)(SOURCE) SWITCH, SLIDE (SEEK/AMS) SWITCH, KEY BOARD (WITH LED)(MODE) SWITCH, ROTARY (D-BASS) SWITCH, KEY BOARD (WITH LED)(SOUND) SWITCH, KEY BOARD (WITH LED)(SHIFT) SWITCH, KEY BOARD (WITH LED)(1) SWITCH, KEY BOARD (WITH LED)(2) SWITCH, KEY BOARD (WITH LED)(3)
LSW811 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(4) LSW812 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(Z) LSW813 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(DSPL) (C7900R) LSW814 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(LIST) (C7900) LSW814 1-762-620-11 SWITCH, KEY BOARD (WITH LED) (PTY/LIST) (C7900R) LSW815 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(DSPL) (C7900) LSW815 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(AF/TA) (C7900R) LSW816 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(10) LSW817 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(9) LSW818 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(8) LSW819 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(7) LSW820 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(6) LSW821 1-762-620-11 SWITCH, KEY BOARD (WITH LED)(5) < PILOT LAMP > PL801 PL802 1-517-630-31 LAMP, PILOT (LCD BACK LIGHT) 1-517-630-31 LAMP, PILOT (LCD BACK LIGHT)
< ROTARY ENCODER > EN801
www..com
1-475-014-11 ENCODER, ROTARY (VOLUME/BASS/TREBLE/BALANCE/FADER CONTROL)
- 68 -
www..com
KEY
Ref. No. Part No. Description < TRANSISTOR > Q801 Q802 Q803 Q804 Q805 Q806 Q807 8-729-424-08 8-729-424-08 8-729-904-78 8-729-904-66 8-729-106-60 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR UN2111 UN2111 DTD113ZK DTD113EK 2SB1115A-YQ Remark Ref. No. R852 R853 R854 R856 R857 R858 R861 R862 R863 R865 R866 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (C7900R) 1/10W (C7900) 1/10W (C7900R) 1/10W (C7900) 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W R867 Part No. Description 22K 5% 1-216-081-00 METAL CHIP 1-216-069-00 1-216-061-00 1-216-049-00 1-216-295-00 1-216-295-00 1-216-041-00 1-216-659-11 1-216-659-11 1-216-061-00 1-216-061-00 METAL CHIP METAL CHIP METAL CHIP SHORT SHORT METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
MAIN
Remark 1/10W 1/10W 1/10W 1/10W
6.8K 5% 3.3K 5% 470 5% 0 (C7900) 0 (C7900) 470 2.2K 2.2K 3.3K 3.3K 3.3K 5% 0.5% 0.5% 5% 5% 5%
8-729-026-53 TRANSISTOR 2SA1576A-T106-QR 8-729-905-35 TRANSISTOR 2SC4081T106R < RESISTOR >
1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
R801 R802 R803 R804 R805 R806 R807 R808 R809 R810 R812 R813 R814 R815 R816 R817 R818 R819 R820 R823 R824 R827 R828 R829 R830 R831 R832 R833 R833 R834
1-216-647-11 1-216-647-11 1-216-647-11 1-216-651-11 1-216-655-11 1-216-655-11 1-216-659-11 1-216-663-11 1-216-667-11 1-216-671-11 1-216-647-11 1-216-647-11 1-216-647-11 1-216-651-11 1-216-655-11 1-216-655-11 1-216-659-11 1-216-663-11 1-216-667-11 1-216-028-00 1-216-023-00 1-216-028-00 1-216-023-00 1-216-028-00 1-216-023-00
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
680 680 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 6.8K 680 680 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 130 82 130 82 130 82 130 82 130 300 82
0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1-216-061-00 METAL CHIP
< CONPOSITION CIRCUIT BLOCK > RB802 1-233-810-21 RES, NETWORK 100K (3216) RB803 1-233-414-11 RES, CHIP NETWORK 4.7K (3216) ************************************************************ * * * * A-3294-393-A MAIN BOARD, COMPLETE (C7900R: AEP, UK) A-3294-394-A MAIN BOARD, COMPLETE (C7900R: German) A-3294-410-A MAIN BOARD, COMPLETE (C7900: US, Canadian) A-3294-412-A MAIN BOARD, COMPLETE (C7900: E) ********************* 3-011-078-01 3-022-317-01 3-023-604-01 7-685-794-09 BRACKET (POWER IC) BRACKET (AMP) HEAT SINK SCREW +PTT 2.6X10 (S) < BUZZER > BZ1 1-504-920-11 BUZZER < CAPACITOR > C1 C2 C3 C3 C4 1-163-235-11 CERAMIC CHIP 1-164-232-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP 1-163-989-11 CERAMIC CHIP 1-163-063-00 CERAMIC CHIP 22PF 5% 50V 0.01uF 50V 0.1uF 10% 25V (C7900: US, Canadian) 0.033uF 10% 25V (C7900: E/C7900R) 0.022uF 10% 50V (C7900: US, Canadian) 50V (C7900: E/C7900R) 0.022uF 10% 50V (C7900: E/C7900R) 0.033uF 10% 25V (C7900: US, Canadian) 0.022uF 10% 50V (C7900: E/C7900R) 0.033uF 10% 25V (C7900: US, Canadian) 0.001uF 100PF 100PF 100PF 0.001uF 10% 5% 5% 5% 10% 50V 50V 50V 50V 50V (C7900R) 50V (C7900) 0.01uF
* * *
1-216-028-00 METAL CHIP 1-216-023-00 METAL CHIP 1-216-028-00 METAL CHIP 1-216-036-00 METAL CHIP 1-216-023-00 METAL CHIP
C4 C5
1-164-232-11 CERAMIC CHIP 1-163-063-00 CERAMIC CHIP 1-163-078-11 CERAMIC CHIP 1-163-063-00 CERAMIC CHIP 1-163-078-11 CERAMIC CHIP
R834 R835 R836 R838 R839 R840 R841 R842 R843 R845 R846 R849 R850
1-216-034-00 METAL CHIP 1-216-048-00 1-216-047-00 1-216-028-00 1-216-023-00 1-216-041-00 1-216-025-00 1-216-048-00 1-216-047-00 1-216-699-11 RES, CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP RES, CHIP METAL CHIP RES, CHIP
240 910 820 130 82 470 100 910 820 100K 1K 1K 4.7K 4.7K
5% 5% 5% 5% 5% 5% 5% 5% 5% 0.5% 0.5% 0.5% 0.5% 0.5%
C5 C6 C6
C7 C8 C9 C10 C11
1-163-009-11 1-163-251-11 1-163-251-11 1-163-251-11 1-163-009-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
1-216-651-11 METAL CHIP 1-216-667-11 METAL CHIP 1-216-667-11 METAL CHIP
R847 1-216-651-11 METAL CHIP www..com
C12
1-163-017-00 CERAMIC CHIP
0.0047uF 10%
- 69 -
www..com
MAIN
Ref. No. C12 C13 C14 C15 C16 C16 C17 C18 C19 Part No. Description 0.0022uF 10% 0.01uF 0.22uF 0.1uF 0.22uF 0.033uF 47uF 0.01uF 0.1uF 10% 10% 10% 10% 20% 10% Remark 100V (C7900R) 50V (C7900R) 25V (C7900R) 25V 25V (C7900) 25V (C7900R) 10V 50V 25V (C7900R) 16V (C7900R) 50V 50V 25V (C7900R) 50V 10V 16V 25V 16V 25V 16V 25V 16V 10V 25V 25V 50V 10V 25V (C7900R) 50V (C7900R) 50V (C7900R) 50V (C7900R) 50V (C7900R) 50V (C7900R) 50V (C7900R) 100V (C7900R) 50V (C7900R) 16V (C7900R) 50V (C7900R) 25V (C7900R) 25V (C7900R) Ref. No. C63 C100 C101 C103 C106 C107 C200 C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C212 C213 C214 C215 C216 C217 C218 C219 C220 C221 C222 C223 C224 C225 C226 C227 C228 C229 C250 C251 C252 C253 C254 C255 C256 C257 C300 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 Part No. Description 0.1uF 4.7uF 4.7uF 4.7uF 10uF 0.1uF 15PF 0.01uF 10uF 0.15uF 0.0033uF 4.7uF 22PF 0.22uF 10uF 0.01uF 22uF 22uF 0.01uF 10% 20% 20% 20% 20% 10% 5% 20% 10% 10% 20% 5% Remark 25V (C7900R) 35V 35V 35V 35V 25V 50V 50V 35V 16V 50V 25V 50V 25V 35V 50V 16V 16V 50V 50V 50V 35V 50V 50V 25V 50V 25V 35V 25V 25V 50V 25V 25V 50V 50V 25V 16V 6.3V 50V 16V 16V 25V 25V 25V 50V 16V 25V 25V 50V 50V 50V 25V 35V 16V 16V 35V 25V 1-164-161-11 CERAMIC CHIP 1-164-232-11 CERAMIC CHIP 1-115-340-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP 1-115-340-11 CERAMIC CHIP 1-163-989-11 CERAMIC CHIP 1-126-785-11 ELECT 1-164-232-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP 1-115-866-11 ELECT 1-115-866-11 ELECT 1-115-866-11 ELECT 1-104-946-11 1-164-004-11 1-163-231-11 1-164-232-11 1-104-946-11 1-164-492-11 1-164-182-11 1-126-794-11 1-163-235-11 1-164-222-11 1-104-946-11 1-164-232-11 1-126-514-11 1-126-514-11 1-164-232-11 1-163-014-00 1-163-014-00 1-104-946-11 1-163-031-11 1-164-232-11 1-164-004-11 1-163-259-00 1-163-038-00 1-104-946-11 1-126-794-11 1-126-794-11 1-163-133-00 1-164-004-11 1-164-004-11 1-163-259-00 1-163-133-00 1-164-004-11 1-126-767-11 1-124-635-00 1-163-259-00 1-126-382-11 1-126-514-11 1-164-004-11 1-126-796-11 1-163-038-00 1-115-872-11 1-164-506-11 1-164-004-11 1-164-004-11 1-115-871-11 1-115-871-11 1-164-182-11 1-163-037-11 1-128-428-11 1-164-492-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C34 C35 C37 C40 C50 C51
1-126-514-11 ELECT 1-163-237-11 CERAMIC CHIP 1-163-237-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP 1-164-182-11 CERAMIC CHIP 1-126-785-11 1-126-382-11 1-164-004-11 1-126-382-11 1-164-004-11 1-126-382-11 1-164-004-11 1-126-382-11 1-128-241-11 1-164-004-11 1-164-004-11 1-164-232-11 1-104-955-11 1-163-038-00 ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP
22uF 27PF 27PF 0.1uF
20% 5% 5% 10%
20% 20% 20%
0.0033uF 10% 47uF 100uF 0.1uF 100uF 0.1uF 100uF 0.1uF 100uF 220uF 0.1uF 0.1uF 0.01uF 100uF 0.1uF 470PF 20% 20% 10% 20% 10% 20% 10% 20% 20% 10% 10% 20%
0.0027uF 10% 0.0027uF 10% 10uF 20% 0.01uF 0.01uF 0.1uF 220PF 0.1uF 10uF 4.7uF 4.7uF 470PF 0.1uF 0.1uF 220PF 470PF 0.1uF 1000uF 220uF 220PF 100uF 22uF 0.1uF 22uF 0.1uF 2.2uF 4.7uF 0.1uF 0.1uF 1uF 1uF 0.0033uF 0.022uF 10uF 0.15uF 0.15uF 10uF 0.047uF 10% 5% 20% 20% 20% 5% 10% 10% 5% 5% 10% 20% 20% 5% 20% 20% 10% 20%
1-163-133-00 CERAMIC CHIP
5%
C52 C53 C54 C55 C56
1-163-104-00 CERAMIC CHIP 1-163-104-00 CERAMIC CHIP 1-163-011-11 CERAMIC CHIP 1-163-125-00 CERAMIC CHIP 1-163-125-00 CERAMIC CHIP
30PF 30PF
5% 5%
0.0015uF 10% 220PF 220PF 5% 5%
20% 10% 10% 20% 20% 10% 10% 20% 10% 10% 20% 10%
C57 C58 C59 C60 C61
1-164-161-11 CERAMIC CHIP 1-163-135-00 CERAMIC CHIP 1-164-505-11 CERAMIC CHIP 1-163-263-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP
0.0022uF 10% 560PF 2.2uF 330PF 0.1uF 5% 10% 5%
C62
www..com
1-163-038-00 CERAMIC CHIP
0.1uF
1-164-492-11 CERAMIC CHIP 1-128-428-11 ELECT 1-163-809-11 CERAMIC CHIP
- 70 -
www..com
MAIN
Ref. No. C313 C314 C315 C316 C317 C318 C319 C320 C321 C322 C323 C324 C325 C400 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 C417 C418 C419 C420 C424 C425 C501 C502 C503 C504 C505 C506 C507 C508 C510 C601 C700 C701 C702 C703 C704 C705 C706 C707 C708 C709 C800 Part No. Description 100uF 4.7uF 4.7uF 100PF 100PF 100PF 0.1uF 0.1uF 0.1uF 100PF 100PF 0.22uF 0.22uF 2.2uF 0.1uF 0.1uF 4.7uF 100uF 0.047uF 1uF 1uF 0.0033uF 0.022uF 10uF 0.15uF 0.15uF 10uF 4.7uF 4.7uF 100PF 100PF 100PF 100PF 100PF 0.22uF 0.22uF 0.1uF 0.47uF 47uF 0.1uF 0.1uF 0.01uF 4700uF 0.1uF 47uF 4.7uF 1uF 1uF 2.2uF 470PF 0.1uF 0.1uF 0.1uF 0.01uF 15PF 8PF 10uF 20% 20% 20% 5% 5% 5% 10% 10% 10% 5% 5% Remark 6.3V 35V 35V 50V 50V 50V 25V 25V 25V 50V 50V 25V 25V 50V 25V 25V 16V 10V 25V 50V 50V 50V 25V 16V 16V 16V 16V 35V 35V 50V 50V 50V 50V 50V 25V 25V 25V 50V 25V 25V 25V 50V 16V 25V 16V 35V 16V 50V 16V 50V 25V 25V Ref. No. C801 C802 C803 C804 C805 C806 C807 C900 C901 C902 C903 C904 C905 C914 C916 Part No. 1-128-428-11 1-128-428-11 1-128-428-11 1-128-428-11 1-128-428-11 1-164-004-11 1-164-346-11 1-115-866-11 1-163-133-00 1-163-133-00 1-104-329-11 1-128-241-11 1-125-710-11 1-163-038-00 Description ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT DOUBLE LAYER CERAMIC CHIP 10uF 10uF 10uF 10uF 10uF 0.1uF 1uF 4.7uF 470PF 470PF 0.1uF 220uF 0.1F 0.1uF 0.1uF 20% 20% 20% 20% 20% 10% 20% 5% 5% 10% 20% Remark 35V 35V 35V 35V 35V 25V 16V 35V 50V 50V 50V 10V 5.5V 25V (Type A) 25V (Type A) 6.3V (Type A) 16V (Type A) 25V 16V 25V 50V 16V 16V 16V 50V 1-126-382-11 ELECT 1-115-866-11 ELECT 1-115-866-11 1-163-251-11 1-163-251-11 1-163-251-11 1-164-004-11 1-164-004-11 1-164-004-11 1-163-251-11 1-163-251-11 1-164-222-11 1-164-222-11 1-115-872-11 1-164-004-11 1-164-004-11 1-164-506-11 1-104-955-11 1-163-809-11 1-115-871-11 1-115-871-11 1-164-182-11 1-163-037-11 1-126-791-11 1-164-492-11 1-164-492-11 1-126-791-11 1-115-866-11 1-115-866-11 1-163-251-11 1-163-251-11 1-163-251-11 1-163-251-11 1-163-251-11 1-164-222-11 1-164-222-11 1-163-038-00 1-115-334-11 1-107-888-11 1-164-004-11 1-164-004-11 1-164-232-11 1-126-016-11 1-164-004-11 1-126-786-11 1-115-866-11 1-164-346-11 1-115-871-11 1-164-505-11 1-163-133-00 1-164-004-11 1-164-004-11 1-164-004-11 1-164-232-11 1-163-231-11 1-163-091-00 1-128-428-11 ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP FILM ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT
20% 10% 10%
1-163-038-00 CERAMIC CHIP
C917 20% 10% 20% 20% 10% 10% 20% 10% 10% 20% 20% 20% 5% 5% 5% 5% 5% C918 C920 C990 C991 C992 C993 C994 C995 C999
1-124-635-00 ELECT 1-126-514-11 ELECT 1-164-004-11 CERAMIC CHIP 1-164-346-11 CERAMIC CHIP 1-164-004-11 CERAMIC CHIP 1-113-342-11 1-164-506-11 1-164-506-11 1-164-506-11 1-163-133-00 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP < CONNECTOR >
220uF 22uF 0.1uF 1uF 0.1uF 0.1uF 4.7uF 4.7uF 4.7uF 470PF
20% 20% 10% 10%
5%
CN200 CN900 CNJ600 CNP300 CNP500
1-764-617-12 1-764-422-11 1-580-907-31 1-774-700-11 1-774-701-11
PIN, CONNECTOR (PC BOARD) 30P PLUG, CONNECTOR 12P PLUG, CONNECTOR (BUS CONTROL IN) JACK, PIN 6P (BUS AUDIO IN/LINE OUT) PIN, CONNECTOR 16P < CONPOSITION CIRCUIT BLOCK >
CP1 5% 20% 10% 10%
1-519-504-11 GAP, DISCHARGE < DIODE >
20% 10% 20% 20%
D1 D3 D4 D5 D200 D201 D202 D300 D301 D302 D303 D500 D501 D502 D503 D504 D505 D506
8-719-977-03 8-719-981-59 8-719-423-10 8-719-421-24 8-719-313-73 8-719-422-31 8-719-423-32 8-719-914-42 8-719-914-42 8-719-914-42 8-719-421-27 8-719-988-62 8-719-017-62 8-719-052-59 8-719-053-18
DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE
DTZ5.6B FC805 MA8100-M-TX MA8039-H SFPB-52 MA8047-M MA8120-M DA204K DA204K DA204K MA728 1SS355 MA8068-L-TX 1N5404TU-15 1SR154-400TE-25
20% 5% 10% 10% 10%
www..com
25V 50V 5% 50V 0.25PF 50V 20% 35V
8-719-053-18 DIODE 1SR154-400TE-25 8-719-053-18 DIODE 1SR154-400TE-25 8-719-053-18 DIODE 1SR154-400TE-25
- 71 -
www..com
MAIN
Ref. No. D507 D508 D509 D510 D600 D601 D602 D603 D604 D700 D701 D702 D800 D801 D802 D803 D900 D901 D902 D903 D904 D905 D906 D907 D908 D909 D910 D911 D912 D913 D914 D916 Part No. Description Remark Ref. No. J900 Part No. Description Remark 8-719-053-18 DIODE 1SR154-400TE-25 8-719-053-18 DIODE 1SR154-400TE-25 8-719-053-18 8-719-053-18 8-719-057-80 8-719-057-80 8-719-017-62 8-719-022-90 8-719-017-62 1-216-049-11 8-719-914-43 8-719-914-44 8-719-053-18 8-719-053-18 8-719-988-62 8-719-400-20 8-719-988-62 8-719-423-23 8-719-017-62 8-719-017-62 8-719-017-62 8-719-017-62 8-719-017-62 8-719-017-62 8-719-017-62 8-719-017-62 8-719-017-62 8-719-423-32 8-719-914-44 8-719-420-14 8-719-053-18 8-719-404-49 DIODE DIODE DIODE DIODE DIODE 1SR154-400TE-25 1SR154-400TE-25 MA8160-M-TX MA8160-M-TX MA8068-L-TX 1-566-822-41 JACK (REMOTE IN) < COIL > L1 L2 L3 L50 L200 L201 L202 L230 L231 L250 L251 L252 L500 L700 L800 1-412-951-11 1-216-296-00 1-412-055-11 1-412-951-11 1-412-955-11 1-412-955-11 1-412-955-11 1-412-955-11 1-412-955-11 1-412-533-21 1-412-537-31 1-412-533-21 1-416-712-21 1-412-058-11 1-414-546-11 INDUCTOR CHIP 10uH SHORT 0 INDUCTOR CHIP 3.3uH INDUCTOR 10uH (C7900R) INDUCTOR 22uH INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 22uH 22uH 22uH 22uH 47uH
DIODE MA8160M DIODE MA8068-L-TX RES, CHIP 1K DIODE DAN202K DIODE DAP202K DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE < IC > 1SR154-400TE-25 1SR154-400TE-25 1SS355 MA152WA 1SS355 MA8110-M MA8068-L-TX MA8068-L-TX MA8068-L-TX MA8068-L-TX MA8068-L-TX MA8068-L-TX MA8068-L-TX MA8068-L-TX MA8068-L-TX
5%
1/10W
INDUCTOR 100uH INDUCTOR 47uH COIL, CHOKE 4700uH INDUCTOR CHIP 10uH INDUCTOR 22uH < TRANSISTOR >
Q1 Q2 Q4 Q5 Q6 Q50 Q51 Q100 Q101 Q102 Q103 Q250 Q251 Q252 Q253 Q254 Q255 Q300 Q301 Q302 Q303 Q400 Q401 Q402 Q403 Q500 Q600 Q601 Q603 Q700 Q701 Q900 Q901 Q902 Q903 Q904 Q905 Q906
8-729-230-49 8-729-120-28 8-729-021-94 8-729-900-53 8-729-920-85 8-729-230-49 8-729-020-67 8-729-920-21 8-729-920-21 8-729-920-21 8-729-020-67 8-729-106-60 8-729-900-53 8-729-920-85 8-729-020-67 8-729-807-12 8-729-020-67 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-120-28 8-729-424-08 8-729-421-22 8-729-920-21 8-729-424-08 8-729-421-22 8-729-120-28 8-729-026-49 8-729-120-28 8-729-026-68
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
2SC2712-YG 2SC1623-L5L6 2SK1657-T1B DTC114EK (C7900R) 2SD1664-QR 2SC2712-YG (C7900R) XN1A312-TX (C7900R) DTC314TKH04 DTC314TKH04 DTC314TKH04 XN1A312-TX 2SB1115A DTC114EK 2SD1664-QR XN1A312-TX 2SD1802-S XN1A312-TX DTC314TKH04 DTC314TKH04 DTC314TKH04 DTC314TKH04 DTC314TKH04 DTC314TKH04 DTC314TKH04 DTC314TKH04 2SC1623-L5L6 UN2111 UN2211 DTC314TKH04 UN2111 UN2211 2SC1623-L5L6 2SA1037AK-T146-R 2SC1623-L5L6 2SD2525(TP)
MA8120-M DAP202K MA8082-M 1SR154-400TE-25 (Type A) MA111
IC100 IC102 IC103 IC200 IC201 IC202 IC203 IC204 IC250 IC300 IC500 IC600 IC700 IC700 IC700 IC700 IC800 IC801 IC802 IC900
8-759-448-85 8-759-492-59 8-759-184-64 8-759-158-96 8-759-473-70 8-759-464-81 8-759-711-82 8-759-238-47 8-759-337-67 8-759-487-82
IC IC IC IC IC IC IC IC IC IC
BU2624FV-E2 SAA6588T-118 (C7900R) TC4W66FU (C7900R) TC9246F-TP1 SM5852FS-E2 PCM1717E-ST2 NJM4580E TC74HCT7007AF(EL) NJM2360AM(TE2) LC75374E
8-759-490-74 IC TDA7384 8-759-449-89 IC BA8270F-E2 8-759-532-49 IC MB90574PFV-G-113-BND (C7900R: Type A) 8-759-532-50 IC MB90574PFV-G-114-BND (C7900: Type A) 8-759-536-84 IC MB90F574PFV-G-113 (C7900R: Type B) 8-759-536-85 8-759-347-50 8-759-363-81 8-759-344-91 8-759-496-74 IC IC IC IC IC MB90F574PFV-G-114 (C7900: Type B) BA3918-V3 XC61AN4002PR RN5VD23AA-TL TA78DL06S (Type A)
< JACK > www..com J1 1-764-808-31 JACK (ANT)(FM/AM ANTENNA)
8-729-026-68 TRANSISTOR 2SD2525(TP) 8-729-924-73 TRANSISTOR FMA9 8-729-921-25 TRANSISTOR FMC2
- 72 -
www..com
MAIN
Ref. No. Q991 Q992 Q993 Part No. Description Remark Ref. No. R104 R105 8-729-424-08 TRANSISTOR UN2111 R105 < RESISTOR > R106 R1 R2 R3 R4 R5 R6 R7 R8 R10 R11 R12 R12 R13 R14 R15 R16 R17 R18 R20 R21 R22 R30 R31 R33 R50 1-216-049-11 1-216-041-11 1-216-077-00 1-216-081-00 1-216-049-11 1-216-037-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-065-00 RES, CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP 1K 470 15K 22K 1K 330 10K 10K 10K 4.7K 10K 15K 0 3.3K 22K 4.7K 4.7K 10K 2.2K 2.2K 2.2K 47K 1K 0 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (C7900) 1/10W (C7900R) 1/10W 1/10W 1/10W (C7900R) 1/10W (C7900R) 1/10W (C7900R) 1/10W 1/10W 1/10W 1/8W (C7900R) 1/8W 1/10W (C7900R) 1/10W (C7900R) 1/10W (C7900R) 1/10W (C7900R) 1/10W (C7900R) 1/10W (C7900R) 1-216-033-00 METAL CHIP 1-216-081-00 METAL CHIP Part No. Description 22K Remark 5% 1/10W (C7900: E/C7900R) 15K 5% 1/10W (C7900: US, Canadian) 22K 5% 1/10W (C7900: E/C7900R) 220 5% 1/10W (C7900R: German) 10K 5% 1/10W (C7900: E/C7900R: AEP, UK) 12K 5% 1/10W (C7900: US, Canadian) 0 47K 5% 1/10W 10K 5% 1/10W 10K 47K 0 100 1.5K 56K 100 120 100 100 100 100 100 100 100 10K 4.3K 3.3K 3.3K 3.3K 3.3K 4.3K 100 100 100 10K 10K 47K 47K 0 100 100 100 0.2 3.3K 2.2K 10K 4.7K 470 10K 4.7K 3.6K 220 22K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 8-729-920-21 TRANSISTOR DTC314TKH04 8-729-920-21 TRANSISTOR DTC314TKH04 1-216-081-00 METAL CHIP 1-216-077-00 METAL CHIP
R106 R106 R107 R109 R111 R112 R114 R116 R200 R201 R202 R203 R204 R205 R206 R207 R208 R209 R210 R211 R212 R214 R215 R216 R217 R218 R219 R220 R221 R222 R224 R225 R227 R228 R229 R230 R231 R232 R250 R255 R256 R257 R258 R259 R260 R302 R303 R304 R305
1-216-073-00 METAL CHIP 1-216-075-00 METAL CHIP 1-216-295-00 SHORT 1-216-089-00 RES, CHIP 1-216-073-00 METAL CHIP 1-216-073-00 1-216-089-00 1-216-295-00 1-216-025-00 1-216-053-00 1-216-091-00 1-216-025-00 1-216-027-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-073-00 1-216-064-00 1-216-061-00 1-216-061-00 1-216-061-00 1-216-061-00 1-216-064-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-073-00 1-216-073-00 1-216-089-00 1-216-089-00 1-216-295-00 1-216-025-00 1-216-025-00 1-216-025-00 1-219-986-11 1-216-663-11 1-216-057-00 1-216-073-00 1-216-065-00 1-216-190-00 1-216-675-11 1-216-065-00 1-216-062-00 1-216-033-00 1-216-081-00 METAL CHIP RES, CHIP SHORT RES, CHIP METAL CHIP METAL CHIP RES, CHIP METAL CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP RES, CHIP RES, CHIP METAL CHIP METAL CHIP RES, CHIP RES, CHIP SHORT RES, CHIP RES, CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP RES, CHIP METAL CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP
1-216-073-00 METAL CHIP 1-216-077-00 METAL CHIP 1-216-295-00 SHORT 1-216-061-00 METAL CHIP 1-216-081-00 METAL CHIP 1-216-065-00 RES, CHIP 1-216-065-00 RES, CHIP 1-216-073-00 METAL CHIP 1-216-057-00 METAL CHIP 1-216-057-00 METAL CHIP 1-216-057-00 METAL CHIP 1-216-238-00 RES, CHIP 1-216-198-00 RES, CHIP 1-216-295-00 SHORT 1-216-097-00 RES, CHIP
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
R51 R52 R53 R55 R56
1-216-113-00 METAL CHIP 1-216-049-11 RES, CHIP 1-216-049-11 RES, CHIP 1-216-041-00 METAL CHIP 1-216-035-00 METAL CHIP
470K 1K 1K 470 270
5% 5% 5% 5% 5%
R57 R58 R103 R103 R103
1-216-035-00 METAL CHIP 1-216-001-00 METAL CHIP 1-216-033-00 METAL CHIP 1-216-073-00 METAL CHIP 1-216-075-00 METAL CHIP
1/10W (C7900R) 10 5% 1/10W (C7900R) 220 5% 1/10W (C7900R: German) 10K 5% 1/10W (C7900: E/C7900R: AEP, UK) 12K 5% 1/10W (C7900: US, Canadian) 15K 5% 1/10W (C7900: US, Canadian)
270
5%
5% 5% 5% 1% 0.5% 5% 5% 5% 5% 0.5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/4W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W
R104 1-216-077-00 METAL CHIP www..com
- 73 -
www..com
MAIN
Ref. No. R306 R307 R308 R309 R310 R311 R312 R313 R402 R404 R405 R406 R407 R408 R409 R410 R411 R412 R413 R414 R500 R501 R502 R503 R504 R505 R506 R600 R601 R602 R603 R700 R701 R702 R703 R705 R706 R708 R709 R711 R712 R713 R714 R715 R716 R717 R718 R719 R720 R721 R722 R723 R724 R725 R726 R727 R728 Part No. Description 22K 220 4.7K 4.7K 47K 47K 12K 10K 4.7K 3.6K 220 22K 22K 220 4.7K 4.7K 47K 47K 10K 12K 1K 2.2K 10K 10K 10K 33K 10K 100 10K 100K 10 10K 10K 330 1K 0 100K 0 47K 0 330 100K 100K 100 100 100 100 100 100 100 100 100 100 100 100 1K 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W Ref. No. R729 R730 R731 R732 R733 R734 R735 R736 R737 R738 R739 R740 R741 R742 R743 R744 R745 R746 R747 Part No. 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-049-11 1-216-025-00 1-216-033-00 1-216-033-00 1-216-025-00 Description RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP 100 100 100 100 1K 100 220 220 100 100 100 100 100 100 100 100 100 100 100 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (C7900R) 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (C7900R) 1/10W (C7900R) 1/10W (C7900R) 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W (C7900R) 1/10W (C7900R) 1/10W 1-216-081-00 METAL CHIP 1-216-033-00 1-216-065-00 1-216-065-00 1-216-089-00 1-216-089-00 1-216-075-00 1-216-073-00 1-216-065-00 1-216-062-00 1-216-033-00 1-216-081-00 1-216-081-00 1-216-033-00 1-216-065-00 1-216-065-00 1-216-089-00 1-216-089-00 1-216-073-00 1-216-075-00 1-216-049-11 1-216-057-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-085-00 1-216-073-00 1-216-025-00 1-216-073-00 1-216-097-00 1-216-150-00 1-216-073-00 1-216-073-00 1-216-037-00 1-216-049-11 1-216-295-00 1-216-097-00 1-216-295-00 1-216-089-00 1-216-295-00 1-216-037-00 1-216-097-00 1-216-097-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-049-11 METAL CHIP METAL CHIP METAL CHIP RES, CHIP RES, CHIP METAL CHIP METAL CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP RES, CHIP METAL CHIP METAL CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP METAL CHIP RES, CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP SHORT RES, CHIP SHORT RES, CHIP SHORT METAL CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP
1-216-025-00 RES, CHIP 1-216-025-00 RES, CHIP 1-216-025-00 RES, CHIP 1-216-025-00 RES, CHIP 1-216-025-00 RES, CHIP 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP
R748 R749 R750 R751 R752 R753 R754 R757 R758 R759 R760 R761 R762 R763 R764 R770 R771 R772 R773 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W R774 R775 R777 R780 R781 R782
1-216-025-00 RES, CHIP 1-216-025-00 RES, CHIP 1-216-025-00 RES, CHIP 1-216-025-00 RES, CHIP 1-216-025-00 RES, CHIP 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-025-00 RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP
100 100 100 100 100 100 100 100 100 100 100 100 100 100 100 100K 100K 3.3K 3.3K 100K 100K 100K 100K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
5% 5% 5%
1/10W 1/10W 1/10W 1-216-061-00 METAL CHIP 1-216-097-00 RES, CHIP 1-216-097-00 RES, CHIP 1-216-097-00 RES, CHIP 1-216-097-00 RES, CHIP 1-216-097-00 RES, CHIP 1-216-097-00 RES, CHIP 1-216-097-00 RES, CHIP 1-216-097-00 RES, CHIP 1-216-061-00 METAL CHIP
5% 1/10W 5% 1/10W 5% 1/10W (C7900: US, Canadian) 100K 5% 1/10W (C7900: E/C7900R) 100K 5% 1/10W (C7900: E) 100K 5% 1/10W (C7900: US, Canadian/C7900R) 470K 5% 1/10W 100K 5% 1/10W 10 5% 1/10W (C7900R) 10K 5% 1/8W
R783 R800 R801 R897 R900
1-216-097-00 RES, CHIP 1-216-113-00 METAL CHIP 1-216-097-00 RES, CHIP 1-216-001-00 RES, CHIP 1-216-222-00 RES, CHIP
www..com
1-216-049-11 RES, CHIP
- 74 -
www..com
MAIN
Ref. No. R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 R911 R912 R913 R914 R915 R916 R917 R918 R919 R920 R921 R924 R930 R981 R990 R991 R992 R993 R994 R995 R996 R997 R999 Part No. 1-216-089-00 1-216-089-00 1-216-675-11 1-216-675-11 1-216-073-00 1-216-067-00 1-216-037-00 1-216-037-00 1-216-298-00 1-216-298-00 1-216-298-00 1-216-298-00 1-216-025-00 1-216-025-00 1-216-025-00 1-216-097-00 1-216-097-00 1-216-675-11 1-216-675-11 1-216-025-00 1-216-025-00 1-216-295-00 1-216-073-00 1-216-121-00 1-216-198-00 1-216-097-00 1-216-097-00 1-216-097-00 1-216-097-00 1-216-057-00 Description RES, CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP RES, CHIP METAL CHIP METAL CHIP RES, CHIP RES, CHIP SHORT METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 47K 47K 10K 10K 10K 5.6K 330 330 2.2 2.2 2.2 2.2 100 100 100 100K 100K 10K 10K 100 100 0 (Type B) 10K 1M 1K 100K 100K 100K 100K 2.2K 5% 5% 0.5% 0.5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 0.5% 0.5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. Part No. Description
SERVO
Remark
X701 1-579-886-21 VIBRATOR, CRYSTAL (32kHz) ************************************************************ * A-3313-612-A SERVO BOARD, COMPLETE *********************** < CAPACITOR > C301 C302 C303 C305 C306 C307 C308 C309 C310 C311 C314 C315 C316 C317 C318 C319 C320 C321 C322 C324 C325 C326 C327 C328 C329 C330 C331 C333 C334 C335 C336 C337 C338 C339 C340 C341 C342 C343 C344 C345 C346 C347 C348 C349 C350 C351 C352 C353 C356 C357 C358 1-107-826-11 1-107-826-11 1-162-927-11 1-162-970-11 1-107-823-11 1-107-826-11 1-162-927-11 1-162-968-11 1-107-823-11 1-164-245-11 1-107-826-11 1-109-982-11 1-107-826-11 1-107-826-11 1-104-852-11 1-104-852-11 1-164-227-11 1-162-969-11 1-162-964-11 1-107-826-11 1-110-563-11 1-162-968-11 1-109-982-11 1-115-467-11 1-164-227-11 1-162-970-11 1-107-826-11 1-107-826-11 1-164-004-11 1-164-004-11 1-162-970-11 1-164-004-11 1-164-004-11 1-162-970-11 1-162-918-11 1-162-918-11 1-162-970-11 1-162-970-11 1-104-852-11 1-162-970-11 1-104-852-11 1-162-970-11 1-107-826-11 1-107-826-11 1-107-826-11 1-104-852-11 1-107-826-11 1-107-826-11 1-162-927-11 1-162-927-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.1uF 100PF 0.01uF 0.47uF 0.1uF 100PF 0.0047uF 0.47uF 0.015uF 0.1uF 1uF 0.1uF 0.1uF 22uF 22uF 0.022uF 0.0068uF 0.001uF 0.1uF 0.068uF 0.0047uF 1uF 0.22uF 0.022uF 0.01uF 0.1uF 0.1uF 0.1uF 0.1uF 0.01uF 0.1uF 0.1uF 0.01uF 18PF 18PF 0.01uF 0.01uF 22uF 0.01uF 22uF 0.01uF 0.1uF 0.1uF 0.1uF 22uF 0.1uF 0.1uF 100PF 100PF 100PF 10% 10% 5% 10% 10% 10% 5% 10% 10% 10% 10% 10% 10% 10% 20% 20% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 10% 5% 5% 10% 10% 20% 10% 20% 10% 10% 10% 10% 20% 10% 10% 5% 5% 5% 16V 16V 50V 25V 16V 16V 50V 50V 16V 25V 16V 10V 16V 16V 6.3V 6.3V 25V 25V 50V 16V 16V 50V 10V 10V 25V 25V 16V 16V 25V 25V 25V 25V 25V 25V 50V 50V 25V 25V 6.3V 25V 6.3V 25V 16V 16V 16V 10V 16V 16V 50V 50V 50V
1-216-097-00 METAL CHIP 1-216-295-00 SHORT 1-216-061-00 METAL CHIP
100K 5% 0 (C7900R) 3.3K 5%
< CONPOSITION CIRCUIT BLOCK > RB900 RB901 1-233-412-11 RES, CHIP NETWORK 1.0K (3216) 1-233-412-11 RES, CHIP NETWORK 1.0K (3216) < VARIABLE RESISTOR > RV1 1-223-591-11 RES, ADJ, CARBON 470K < SWITCH > S700 S701 S900 1-572-552-21 SWITCH, SLIDE (POWER SELECT) 1-572-552-21 SWITCH, SLIDE (FREQUENCY SELECT) (C7900: E) 1-692-431-21 SWITCH, TACTILE (RESET) < THERMISTOR > TH600 1-801-792-21 THERMISTOR, POSITIVE < TUNER > TU1 A-3282-029-A TUNER UNIT TUX-006/2 (E) < VIBRATOR > X1 1-760-838-21 VIBRATOR, www..com CRYSTAL (7.2MHz) X2 X700
1-579-242-11 VIBRATOR, CRYSTAL (4.332MHz)(C7900R) 1-767-833-21 VIBRATOR, CERAMIC (3.68MHz)
1-162-927-11 CERAMIC CHIP
- 75 -
www..com
SERVO
Ref. No. C359 C361 C362 C402 C403 C501 C503 C504 C505 C506 C510 C511 C512 C513 C514 C515 C516 Part No. 1-162-923-11 1-135-259-11 1-107-826-11 1-162-970-11 1-107-826-11 1-162-927-11 1-107-826-11 1-107-826-11 1-107-826-11 1-104-852-11 1-115-467-11 1-107-826-11 1-107-826-11 1-107-826-11 Description CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP TANTAL. CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 47PF 10uF 0.1uF 0.01uF 0.1uF 100PF 0.1uF 0.1uF 0.1uF 22uF 0.22uF 0.1uF 0.1uF 0.1uF 0.22uF 0.1uF 0.1uF 5% 20% 10% 10% 10% 5% 10% 10% 10% 20% 10% 10% 10% 10% 10% 10% 10% Remark 50V 6.3V 16V 25V 16V 50V 16V 16V 16V 10V 10V 16V 16V 16V 10V 16V 16V Ref. No. Q402 Q403 Part No. Description Remark 8-729-106-60 TRANSISTOR 2SB1115A 8-729-421-22 TRANSISTOR UN2211 < RESISTOR > R301 R302 R303 R304 R305 R306 R307 R308 R310 R313 R314 R315 R318 R319 R320 R324 R325 R327 R328 R329 R330 R331 R332 R333 R334 R335 R336 R337 R338 R339 R340 R341 R342 R343 R344 R345 R346 R347 R348 R349 R350 R351 R352 R353 R354 R355 R356 R357 R401 R402 R403 R404 R405 R406 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-821-11 1-216-825-11 1-216-821-11 1-216-809-11 1-216-833-11 1-216-845-11 1-216-855-11 1-216-827-11 1-216-821-11 1-216-821-11 1-216-811-11 1-216-819-11 1-216-853-11 1-216-809-11 1-216-809-11 1-216-819-11 1-216-809-11 1-216-815-11 1-216-853-11 1-216-853-11 1-216-833-11 1-216-827-11 1-216-843-11 1-216-837-11 1-216-833-11 1-216-827-11 1-216-833-11 1-216-827-11 1-216-841-11 1-216-833-11 1-218-708-11 1-216-025-00 1-216-142-00 1-218-700-11 1-218-700-11 1-218-700-11 1-216-857-11 1-216-833-11 1-216-833-11 1-216-017-00 1-216-073-00 1-216-065-00 1-216-065-00 1-216-809-11 1-218-692-11 1-218-714-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES, CHIP METAL CHIP RES, CHIP RES, CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 100 100 100 100 100 100 1K 2.2K 1K 100 10K 100K 680K 3.3K 1K 1K 150 680 470K 100 100 680 100 330 470K 470K 10K 3.3K 68K 22K 10K 3.3K 10K 3.3K 47K 10K 4.7K 100 4.7 2.2K 2.2K 2.2K 1M 10K 10K 47 10K 4.7K 4.7K 100 1K 8.2K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 0.50% 5% 5% 0.50% 0.50% 0.50% 5% 5% 5% 5% 5% 5% 5% 5% 0.50% 0.50% 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/10W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/10W 1/10W 1/10W 1/10W 1/16W 1/16W 1/16W
1-115-467-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP 1-107-826-11 CERAMIC CHIP < CONNECTOR >
CN101 CN102 CN103
1-779-389-21 HOUSING,CONNECTOR(PC BOARD)30P 1-573-929-11 CONNECTOR, FFC/FPC (ZIF) 20P 1-764-439-21 CONNECTOR, FPC 11P < DIODE >
D401 D501
8-719-157-93 DIODE RD3.0SB2 8-719-988-62 DIODE 1SS355 < FERRITE BEAD >
FB301 FB302
1-414-235-11 INDUCTOR CHIP 0uH 1-414-385-11 INDUCTOR CHIP 0uH < IC >
IC301 IC302 IC303 IC304 IC305 IC306 IC307 IC401 IC501 IC502 IC503
8-752-384-47 8-752-074-77 8-759-430-25 8-759-096-87 8-759-040-83 8-759-058-62 8-759-498-44 8-759-909-71 8-752-893-33 8-759-238-47
IC IC IC IC IC IC IC IC IC IC
CXD2652AR CXA2523R BH6511FS-E2 TC7WU04FU(TE12R) BA6287F TC7S08FU(TE85R) MSM51V4400-70TS-K BA4558F CXP84340-089Q TC74HCT7007AF(EL)
8-759-238-47 IC TC74HCT7007AF(EL) < COIL >
L301 L302 L303 L304 L305 L306 L501
1-412-058-11 1-412-058-11 1-412-039-51 1-412-039-51 1-412-039-51
INDUCTOR CHIP INDUCTOR CHIP INDUCTOR CHIP INDUCTOR CHIP INDUCTOR CHIP
10uH 10uH 100uH 100uH 100uH
1-412-039-51 INDUCTOR CHIP 100uH 1-412-058-11 INDUCTOR CHIP 10uH < TRANSISTOR >
Q301 Q302 Q401
8-729-230-49 TRANSISTOR 2SC2712-YG www..com
8-729-026-49 TRANSISTOR 2SA1037AK-T146-R 8-729-920-85 TRANSISTOR 2SD1664-QR
- 76 -
www..com
SERVO
Ref. No. R501 R502 R503 R504 R505 R506 R507 R510 R512 R516 R517 R518 R519 R520 R521 R522 R523 R524 R525 R526 R527 R528 R529 R530 R531 R532 R533 R534 R535 R536 R537 R538 R540 R542 R545 Part No. Description 1K 1K 1K 1K 1K 100K 4.7K 100K 100K 100 100 100 100 100 100 1K 1K 1K 100K 2.2K 2.2K 2.2K 2.2K 2.2K 100K 0 100K 100K 100K 0 100 100K 100K 100K 0 5% 5% 5% 5% 5% 5% 0.50% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W Ref. No. Part No. Description Remark 1-216-821-11 METAL CHIP 1-216-821-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-845-11 1-218-708-11 1-216-845-11 1-216-845-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-821-11 1-216-821-11 1-216-821-11 1-216-845-11 1-216-825-11 1-216-825-11 1-216-825-11 1-216-825-11 1-216-825-11 1-216-845-11 1-216-864-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-864-11 1-216-809-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-864-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP M901 A-3301-407-A MOTOR ASSY, SP (SPINDLE) M902 A-3291-190-A MOTOR ASSY, SL (SLED) M903 A-3291-191-A MOTOR ASSY, LO (LOADING) ************************************************************ ************** HARDWARE LIST ************** #1 #2 #3 #4 #5 7-621-772-10 7-685-792-09 7-685-794-09 7-685-106-19 7-685-851-04 SCREW +B 2X4 SCREW +PTT 2.6X6 (S) SCREW +PTT 2.6X10 (S) SCREW +P 2X10 TYPE2 NON-SLIT SCREW +BVTT 2X4 (S)
#6 7-624-102-04 STOP RING 1.5, TYPE-E #7 7-627-852-37 PRECISION SCREW +P 1.7X1.8 TYPE3 #8 7-621-772-08 SCREW +B 2X3 #9 7-621-555-10 SCREW +K 2X3 #10 7-627-554-07 SCREW,PRECISION +P 2X2.2 ************************************************************ ACCESSORIES & PACKING MATERIALS ******************************** 1-473-067-71 3-012-070-01 X-3373-617-1 3-862-552-11 REMOTE COMMANDER (RM-X4S) LABEL (SOUND) (2) (for RM-X4S) CASE ASSY (for FRONT PANEL) MANUAL, INSTRUCTION (ENGLISH, SPANISH, CHINESE) (C7900: E) 3-862-552-21 MANUAL, INSTRUCTION (ENGLISH, SPANISH, SWEDISH, PORTUGUESE) (C7900R: AEP, UK) 3-862-552-31 MANUAL, INSTRUCTION (FRENCH, GERMAN, DUTCH, ITALIAN) (C7900R: AEP) 3-862-552-41 MANUAL, INSTRUCTION (GERMAN) (C7900R: German) 3-862-552-51 MANUAL, INSTRUCTION (ENGLISH) (C7900: US, Canadian) 3-862-552-61 MANUAL, INSTRUCTION (FRENCH) (C7900: Canadian) 3-862-553-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH, SPANISH, CHINESE) (C7900: E) 3-862-553-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH, SPANISH, SWEDISH, PORTUGUESE) (C7900R: AEP, UK) 3-862-553-31 MANUAL, INSTRUCTION, INSTALL (FRENCH, GERMAN, DUTCH, ITALIAN) (C7900R: AEP, German) 3-862-553-41 MANUAL, INSTRUCTION, INSTALL (ENGLISH, FRENCH) (C7900: US, Canadian) ************************************************************ PARTS FOR INSTALLATION AND CONNECTIONS *************************************** 501 502 503 504 505 3-009-613-21 FRAME 3-932-910-11 COLLAR (CDX) 3-924-961-01 SUPPORT (ND), FITTING (C7900: US, Canadian) X-3370-076-1 SCREW ASSY (U.KEY), FITTING (C7900: US, Canadian) X-3370-077-1 SCREW ASSY (AE.KEY), FITTING (C7900: E/C7900R) X-3373-432-1 BRACKET ASSY (for RM-X4S) Les composants identifies par une marque 0 sont critiques pour la securite. Ne les remplacer que par une piece portant le nemero specifie.
< CONPOSITION CIRCUIT BLOCK > RB301 RB302 RB503 1-233-576-11 RES, CHIP NETWORK 100 1-233-576-11 RES, CHIP NETWORK 100 1-233-412-11 RES, CHIP NETWORK 1.0K (3216) < THERMISTOR > TH501 1-810-421-11 THERMISTOR NTH5G36B103K01TE < VIBRATOR > X301 1-767-429-21 VIBRATOR, CRYSTAL (22.5792MHz) X501 1-760-365-11 VIBRATOR, CERAMIC (10MHz) ************************************************************ MISCELLANEOUS *************** 13 13 151 F1 1-776-207-71 CORD (WITH CONNECTOR) (POWER) (C7900) 1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER) (C7900R) 1-654-693-11 SENSOR FLEXIBLE BOARD 8-583-037-02 OPTICAL PICK-UP KMS-241A/J2RP 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A)
0 169 www..com
506
- 77 -
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
MDX-C7900/C7900R
www..com
Ref. No. 507 508 509 510
Part No.
Description
Remark
1-776-207-71 CORD (WITH CONNECTOR) (POWER) (C7900) 3-934-325-01 SCREW, +K (5X8) TAPPING (C7900) 1-776-527-71 CORD (WITH CONNECTOR) (ISO) (POWER) (C7900R) 1-465-459-21 ADAPTER, ANTENNA (C7900R)
501
502
503
504
505
506
507
508
509
510
www..com
- 78 -
www..com
MDX-C7900/C7900R
MEMO
www..com
- 79 -
www..com
MDX-C7900/C7900R
REVISION HISTORY
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.1 1.0 Date 2001.08 1998.04 1998.03 1998.02 Description of Revision Supplement-1, Correction-1 are included. Correction-1 Supplement-1 New
www..com

▲Up To Search▲

Price & Availability of MDX-C7900

	To Download MDX-C7900 Datasheet File
If you can't view the Datasheet, Please click here to try to view without PDF Reader .