filename: tfs 240l.doc version 1.1 15.07.2004 vi telefilter filter specification tfs 240l 1/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m measurement condition ambient temperature t a : 25 c input pow er level: 0 dbm terminating impedances at f c *: input: 360 ? // -9,6 pf output: 360 ? // -10,0 pf ch aracteristics remark : reference lev e l for the relativ e attenuation a rel of the TFS240L is the in sertion loss. the minimum of the pass band attenuation a min is defined as the insertion loss a e . the centre frequency f c is the arithmetic mean v a lue of the upper and low e r frequencies at the 25 db filter attenuation lev e l relativ e to the insertion loss a e . the temperature coefficient of frequency tc f is v a lid both for the reference frequency f c and the frequency response of the filter in the operating temperature range . data ty p. v a lue tolerance / limit insertion loss a e 5,2 db max. 9 db centre frequency f c - 240 mhz 25 khz (reference frequency at ambient temperature) passband ripple (p-p) f c 100 khz 0,2 db max. 0,5 db relativ e attenuation a rel f c ......... f c 0,1 mhz 0,2 db max. 0,5 db f c 0,1 mhz ......... f c 0,15 mhz 0,5 db max. 1 db f c 0,375 mhz ......... f c 0,575 mhz 35 db min. 25 db f c 0,575 mhz ......... f c 0,975 mhz 40 db min. 30 db f c 0,975 mhz ......... f c 5 mhz 40 db min. 35 db 10 mhz ......... f c - 5 mhz 48 db min. 38 db f c + 5 mhz ......... f c + 360 mhz 48 db min. 38 db triple transit response suppression 18 db min. 15 db group delay ripple in f c 100 khz 250 ns max. 400 ns a v erage group delay in f c 100 khz 1,8 s max. 2,4 s return loss in f c 150 khz 12 db min. 7 db input pow e r lev e l - max . 20 dbm***) operating temperature range - - 30 c.... + 80 c storage temperature range - - 40 c.... + 85 c temperature coefficient of frequency tc f ** -0,04 ppm/k 2 - frequency inv e rsion temperature t 0 28 c - *) the terminating impedances depend on parasitics and q-v a lues of matching elem ents and the board used, and are to be understood as reference v a lues only . should there be additional ques tions do not hesitate to ask for an application note or contact ou r design team. **) ? f(h z ) = t c f (ppm/k2) x (t-t 0 )2 x f to (mhz) ***) t h is pow er lev e l is allow ed for short term operation (10% of life tim e ) only , the m a x . i nput pow er for continuous operatio n is 15 dbm generated: checked / approv ed: vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 240l.doc version 1.1 15.07.2004 vi telefilter filter specification tfs 240l 2/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m f ilter ch aracteristic cons truc tion a nd pin c onne c t ion 234 235 . 2 236. 4 237. 6 238. 8 240 24 1. 2 24 2. 4 243. 6 244. 8 246 - 100 -9 0 -8 0 -7 0 -6 0 -5 0 -4 0 -3 0 -2 0 -1 0 0 f r equenc y in m h z m 239. 75 239. 8 239. 85 239. 9 239. 95 240 240. 05 240. 1 240. 15 240. 2 240. 25 -1 0 -9 -8 -7 -6 -5 -4 -3 -2 -1 0 f r equenc y in m h z m a g n i t u d e i n d b 239. 75 239. 8 239. 85 239. 9 239. 95 240 240. 05 240. 1 240. 15 240. 2 240. 25 1. 38 1. 68 1. 98 2. 28 2. 5 8 2. 8 8 3. 18 3. 48 3. 78 4. 08 4. 38 f r equenc y in m h z d e l a y i n s (all dimensions in mm) 50 oh m t est circu i t stability characteristics 2 4 , 6 4 0, 9 0 , 1 2 , 6 2, 3 1 , 0 2 1 , 9 1 0, 3, 5 x 4 , 8 1 0 9 8 7 6 1 2 3 4 5 d a t e c o d e / b a t c h n o . l2 c2 6 1 10 5 2, 3, 4, 7, 8, 9 10 5 pm246 13/2 s29 / 01 1 output 2 ground 3 ground 4 ground 5 input rf return 6 input 7 ground 8 ground 9 ground 10 output rf return date code: y ear + w eek s 2004 t 2005 u 2006 ... a g n i t u d e i n d b c1 l1 vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 240l.doc version 1.1 15.07.2004 vi telefilter filter specification tfs 240l 3/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m after the follow i ng tests the filter shall meet the w hole specification: 1. shock: 500g, 18 ms, half sine w a ve, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5g respective ly , 1 octave per min, 10 cy cles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cy cles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow ): reflow possible: tw ice max.; for temperature conditions, please refer to the attached "air reflow temperature conditions" on page 4; packin g tape & reel: din iec 286 ? 3, w i th excepti on of value for n and minimum bending radius; tape ty pe ii, embossed carrier tape w i th top cover tape on the upper side; max. pieces of filters per reel: 1000 reel of empty components at start: min 300 mm reel of empty components at start including leader: min 500 mm trailer min 300 mm so w p1 do po p2 bo ao e d1 ct s p e c - g u r t 00 61 / 19 x6, 5 q0 9 016:02 .0 0 1 pul l o f f dire ction vi e w di r e ctio n x x t ko x- x jul . 1 0 , 0 1 tape (al l di mensi ons i n mm) w : 44 0,3 po : 4 0,1 do : 1,5 + 0,1 e : 1,75 0,1 f : 20,25 0,05 g (min) : 0,75 p2 : 2 0,05 p1 : 16 0,1 d1(min) : 2,0 a o : 9,3 0,1 bo : 24,9 0,1 ct : 38 0,2 n w w c reel (all dimensions in mm): a : 330 w1 : 44,4 +2,0 / - 0 w2 (max) : 50,4 n (min) : 100 a the minimum bending radius is 45 mm. the mount ing surface of the filters faces the bottom side of the embossed carrier tape. th e marking of the filters is able to read if the view is direct ed on the upper side of the carrier tape in the above show n directi on. vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 240l.doc version 1.1 15.07.2004 vi telefilter filter specification tfs 240l 4/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m a i r re flow te mpe r a t ure c onditions 1st and 2nd air reflow profile name: pre-heating periods main-heati ng periods peak temperature temperature: 150 c - 170 cover 200 c 255 c 5 c t i m e : 60 sec. - 90 sec. 20 sec. - 25 sec. a i r r e flow pr ofile 0 20 40 60 80 100 120 140 160 180 200 220 240 260 0 2 0 4 0 6 0 8 0 100 120 140 160 180 200 220 240 ti m e / se c. t e mperat ure / c table for temperature vs. time during the air reflow process tolerance of temperatures: 5 c time / sec. temperature / c time / sec. temperature / c 0 23 140 160 10 34 150 161 20 46 160 164 30 60 170 170 40 80 180 180 50 103 190 205 60 121 195 230 70 134 200 255 80 143 205 230 90 150 210 205 100 154 215 180 110 156 220 165 120 158 230 140 130 159 240 120 vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
filename: tfs 240l.doc version 1.1 15.07.2004 vi telefilter filter specification tfs 240l 5/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.co m history ve rs ion re a s on of cha nge s na me da te 1.0 generation of specification pfeiffer 02.04.2004 1.1 filter characteristic added pfeiffer 15.07.2004 labelling changed (no. of batch included) vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein w i thout notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation.
|
